RQUE SPECS2016 Tesla Model S torque specs
P85D Dual Motor AWD
Change vehicle
Most looked up
- Lug nuts129 lb-ft175 Nm
- Spark plugs15 lb-ft20 Nm
- Front caliper bracket bolts88 lb-ft120 Nm
- Rear caliper bracket bolts83 lb-ft113 Nm
- Front axle nut184 lb-ft250 Nm
- Outer tie rod end nut40 lb-ft54 Nm
Maintenance
AC System Diagnosis2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Connector Bolts5 lb-ft7 Nm
Battery Test4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Charging System Test1 spec
- Connector Bolts5 lb-ft7 Nm
Check Engine Light Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Cooling System Pressure Test1 spec
- Connector Bolts5 lb-ft7 Nm
Diagnostic Scan3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Differential Service4 specs
- Connector Bolts5 lb-ft7 Nm
- Drain PlugNew washer30 lb-ft41 Nm
- Fill Plug30 lb-ft41 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
Drivability Diagnosis2 specs
- Air Box Clips4 lb-ft5 Nm
- Connector Bolts5 lb-ft7 Nm
Electrical Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Fluid Leak Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Noise Diagnosis2 specs
- Connector Bolts5 lb-ft7 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Power Steering Service4 specs
- Air Box ClipsVerify sequence with the service manual4 lb-ft5 Nm
- Connector Bolts5 lb-ft7 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
Tire Balance2 specs
- Connector Bolts5 lb-ft7 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Tire Mount and Balance2 specs
- Connector Bolts5 lb-ft7 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Tire Rotation2 specs
- Lug Nuts - Alloy WheelsTorque in star pattern, recheck after 50 miles129 lb-ft175 Nm
- Lug Nuts - Steel WheelsTorque in star pattern129 lb-ft175 Nm
TPMS Relearn1 spec
- Connector Bolts5 lb-ft7 Nm
TPMS Sensor2 specs
- Connector Bolts5 lb-ft7 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Transmission Service1 spec
- Connector Bolts5 lb-ft7 Nm
Tune-Up - Major3 specs
- Air Box Clips4 lb-ft5 Nm
- Connector Bolts5 lb-ft7 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
Tune-Up - Minor3 specs
- Air Box Clips4 lb-ft5 Nm
- Connector Bolts5 lb-ft7 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
Wheel Alignment9 specs
- Air Box Clips4 lb-ft5 Nm
- Cam BoltsAfter adjustment95 lb-ft129 Nm
- Camber BoltsIf adjustable55 lb-ft75 Nm
- Connector Bolts5 lb-ft7 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Subframe BoltsIf adjusted85 lb-ft115 Nm
- Tie Rod Jam Nuts41 lb-ft55 Nm
- Tie Rod Lock NutAfter adjustment50 lb-ft68 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brakes
ABS Module5 specs
- ABS Module Bolts7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
ABS Pump3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
ABS Tone Ring4 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
ABS Wheel Speed Sensor - Front5 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Bearing Hub Bolts81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
ABS Wheel Speed Sensor - Rear4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Bleed - All Four3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Booster6 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Booster NutsVerify sequence with the service manual18 lb-ft25 Nm
- Brake Pedal Pushrod LockVerify sequence with the service manual11 lb-ft15 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Master Cylinder NutsVerify sequence with the service manual18 lb-ft25 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Booster Check Valve1 spec
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
Brake Caliper - Front3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
Brake Caliper - Rear3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended83 lb-ft113 Nm
Brake Caliper Bracket6 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Brake Hose Banjo BoltNew copper washers30 lb-ft41 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Caliper Rebuild - Front5 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Caliper Rebuild - Rear5 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Caliper Slide Pins4 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Drum - Rear3 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Fluid Flush7 specs
- Air Box ClipsVerify sequence with the service manual4 lb-ft5 Nm
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Connector Bolts5 lb-ft7 Nm
- Master Cylinder CapHand tight3 lb-ft4 Nm
- Oil Drain PlugUse new crush washer. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Hose - Front5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers. Verify sequence with the service manual18 lb-ft25 Nm
- Brake Hose BracketVerify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Hose - Rear5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers. Verify sequence with the service manual18 lb-ft25 Nm
- Brake Hose BracketVerify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Light Switch1 spec
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
Brake Line - Single3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Lines - Complete Set3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Master Cylinder2 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Nuts18 lb-ft25 Nm
Brake Master Cylinder Rebuild3 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Mounting Nuts18 lb-ft25 Nm
- Reservoir Mounting Bolts6 lb-ft8 Nm
Brake Pads - Front3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Pads - Rear3 specs
- Caliper Bracket BoltsThreadlocker recommended83 lb-ft113 Nm
- Caliper Slide Pin BoltsApply silicone brake grease22 lb-ft30 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Pads and Rotors - Front7 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Pads and Rotors - Rear7 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Bracket BoltsUse thread locker83 lb-ft113 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Proportioning Valve5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Line FittingsUse flare nut wrench. Verify sequence with the service manual11 lb-ft15 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Proportioning Valve BoltsVerify sequence with the service manual11 lb-ft15 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Brake Rotor - Front Single7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Rotor - Rear Single7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts83 lb-ft113 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Rotors - Front Pair7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Brake Rotors - Rear Pair7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts83 lb-ft113 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Drum Brake Hardware Kit2 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Drum Brake Shoes - Rear3 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual83 lb-ft113 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Electronic Parking Brake Motor3 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Front Brake Pad Replacement3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Parking Brake Actuator3 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Parking Brake Cable5 specs
- Bleeder Screw10 lb-ft14 Nm
- Cable Bracket BoltsVerify sequence with the service manual9 lb-ft12 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Equalizer NutAdjust for proper tension. Verify sequence with the service manual11 lb-ft15 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Parking Brake Shoes5 specs
- Adjuster LockVerify sequence with the service manual4 lb-ft5 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Hold-Down SpringsVerify sequence with the service manual6 lb-ft8 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual129 lb-ft175 Nm
Wheel Cylinder3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Engine
Camshaft Position Sensor5 specs
- Camshaft Position Sensor7 lb-ft10 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Connecting Rod Bearings6 specs
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Crankshaft Position Sensor4 specs
- Crankshaft Position Sensor7 lb-ft10 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Engine R&R13 specs
- AC Compressor Bolts18 lb-ft25 Nm
- Alternator Mounting Bolts37 lb-ft50 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Power Steering Pump Bolts18 lb-ft25 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Starter Mounting Bolt37 lb-ft50 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Freeze Plug - Single4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Freeze PlugUse sealant on edges7 lb-ft10 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Freeze Plugs - All4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Freeze PlugUse sealant on edges7 lb-ft10 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Front Main Seal8 specs
- Crankshaft Pulley BoltOften TTY, may need impact133 lb-ft180 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltFront section only9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Cover Bolts - 10mmTighten in sequence33 lb-ft45 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
Harmonic Balancer4 specs
- Crankshaft Pulley BoltOften TTY - check spec, may require impact. Verify sequence with the service manual133 lb-ft180 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Idle Air Control Valve4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- IAC Valve Screws2 lb-ft3 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Idler Pulley4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Idler Pulley Bolt33 lb-ft45 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Knock Sensor4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Knock SensorTorque critical for function15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Long Block Replacement16 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Cylinder Head BoltsTTY - tighten in sequence plus angle48 lb-ft65 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Intake Manifold Bolt18 lb-ft25 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Main Bearings9 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Flywheel BoltsOften TTY, tighten in star pattern. Verify sequence with the service manual70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle. Verify sequence with the service manual55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer. Verify sequence with the service manual26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence. Verify sequence with the service manual9 lb-ft12 Nm
- Oil Pump Pickup TubeVerify sequence with the service manual9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Transmission-to-Engine BoltsVerify sequence with the service manual41 lb-ft55 Nm
Oil Level Sensor5 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Level Sensor11 lb-ft15 Nm
- Oil Pan BoltIf access needed9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pan Replacement6 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence9 lb-ft12 Nm
- Oil Pump Pickup Tube9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pressure Sensor4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Pressure SensorUse thread sealant15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pump8 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Oil Pump Bolts9 lb-ft12 Nm
- Oil Pump Pickup Tube9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
Rear Main Seal9 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltRear section9 lb-ft12 Nm
- Rear Main Seal Housing9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Short Block Replacement12 specs
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Crankshaft Pulley BoltOften TTY - check spec, may require impact133 lb-ft180 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Oil Pump Bolts9 lb-ft12 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Throttle Position Sensor4 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- TPS Screws2 lb-ft3 Nm
Transmission Mount10 specs
- Crossmember Bolt70 lb-ft95 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Mount Bolts48 lb-ft65 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Valve Job - Complete12 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Camshaft Sprocket BoltsHold cam with wrench on hex59 lb-ft80 Nm
- Cylinder Head BoltsTTY - tighten in sequence plus angle48 lb-ft65 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Intake Manifold Bolt18 lb-ft25 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Seals8 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Rocker Arm Shaft BoltsTighten evenly in sequence18 lb-ft25 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Spring - Single6 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Springs - All8 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Rocker Arm Shaft BoltsTighten evenly in sequence18 lb-ft25 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Variable Valve Timing Actuator10 specs
- Cam Phaser BoltApply threadlocker, hold cam stationary48 lb-ft65 Nm
- Camshaft Sprocket BoltsHold cam with wrench on hex59 lb-ft80 Nm
- Crankshaft Pulley BoltOften TTY - check spec, may require impact133 lb-ft180 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
VVT Solenoid - Single5 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
VVT Solenoids - All6 specs
- Camshaft Position Sensor7 lb-ft10 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
Cooling
Coolant Flush2 specs
- Block Drain PlugIf equipped, use new washer18 lb-ft25 Nm
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
Cooling Fan Assembly6 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Cooling Fan Clutch5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Cooling Fan Motor7 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Electrical Connector4 lb-ft5 Nm
- Fan Bolts8 lb-ft11 Nm
- Fan Motor Bolts6 lb-ft8 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Cooling Fan Relay4 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Engine Oil Cooler6 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Heater Control Valve6 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
- Valve Mounting6 lb-ft8 Nm
Heater Core8 specs
- Dashboard Screws2 lb-ft3 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Heater Core Mounting6 lb-ft8 Nm
- Heater Hose Clamps2 lb-ft3 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Heater Hoses6 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Radiator4 specs
- Drain PetcockPlastic - hand tight4 lb-ft5 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped18 lb-ft25 Nm
- Upper/Lower Hose Clamps2 lb-ft3 Nm
Radiator Removal and Service4 specs
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
- Fan Shroud Bolts7 lb-ft10 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped, use new washers18 lb-ft25 Nm
Thermostat Housing3 specs
- Coolant Outlet/Housing BoltsTighten in sequence9 lb-ft12 Nm
- Coolant Temperature Sensor15 lb-ft20 Nm
- Hose ClampsSpring or constant-tension preferred2 lb-ft3 Nm
Fuel system
Charcoal Canister5 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Line FittingsUse new O-rings18 lb-ft25 Nm
- Hose Clamps2 lb-ft3 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
EVAP Purge Valve4 specs
- Filter Bracket8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
EVAP Vent Valve4 specs
- Filter Bracket8 lb-ft11 Nm
- Hose Clamps2 lb-ft3 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Electrical
Airbag - Driver5 specs
- Airbag Module BoltsTorx - disconnect battery and wait 2 minutes5 lb-ft7 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Steering Wheel Nut40 lb-ft54 Nm
Airbag - Passenger5 specs
- Airbag Module BoltsTorx - disconnect battery and wait 2 minutes5 lb-ft7 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Dashboard Fasteners3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Airbag - Side5 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Seat Mounting BoltsSafety critical45 lb-ft61 Nm
- Side Airbag Module BoltsTorx5 lb-ft7 Nm
Airbag Module/Computer4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Amplifier4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Antenna2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Backup Camera4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery3 specs
- Battery Hold-Down Bolt6 lb-ft8 Nm
- Battery Terminal BoltsDo not overtighten - can crack terminal4 lb-ft6 Nm
- Battery Tray Bolts9 lb-ft12 Nm
Battery Cable - Negative6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery Cable - Positive5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Battery Cables - Both6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery Terminal6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Blower Motor2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Blower Motor Resistor Screws1.5 lb-ft2 Nm
Blower Motor Control Module3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Blower Motor Resistor4 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Resistor Screws1.5 lb-ft2 Nm
Clock Spring7 specs
- Airbag Module BoltsTorx - disconnect battery first5 lb-ft7 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Clock Spring ScrewsAlign marks before removal3 lb-ft4 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Steering Column CoversPlastic clips2 lb-ft3 Nm
- Steering Wheel Nut40 lb-ft54 Nm
Combination Switch4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Dimmer Switch3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Door Lock Actuator - Front2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Door Lock Actuator - Rear2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Fog Light Assembly2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Fog Light Bulb1 spec
- Connector Screws3 lb-ft4 Nm
Fuse Box - Engine Bay4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Fuse Box - Interior4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Headlight Assembly5 specs
- Adjuster Screws2 lb-ft3 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Headlight Assembly Bolts7 lb-ft10 Nm
Headlight Bulb - Single4 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Bulb Retaining Ring4 lb-ft5 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Headlight Bulbs - Pair1 spec
- Connector Screws3 lb-ft4 Nm
Headlight Switch3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Heated Seat Module3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
HID Ballast3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Horn4 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Horn Mounting Bolt11 lb-ft15 Nm
Horn Relay2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Instrument Cluster3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
LED Headlight Module3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Main Relay3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Antenna Motor2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Power Mirror Motor2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Power Seat Motor3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Motor - Front3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Motor - Rear3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Regulator - Front3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Regulator - Rear2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Radio/Head Unit3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Relay - Generic3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Seat Heater Element4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Side Mirror Assembly2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Speaker - Dash3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Speaker - Door2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Speedometer4 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Starter Solenoid4 specs
- Battery Cable Nut10 lb-ft14 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Starter Mounting Bolt35 lb-ft47 Nm
Subwoofer3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Sunroof Motor3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Sunroof Switch2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Tail Light Assembly5 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Lens Screws1.5 lb-ft2 Nm
- Tail Light Bolts6 lb-ft8 Nm
Tail Light Bulb1 spec
- Connector Screws3 lb-ft4 Nm
Third Brake Light1 spec
- Connector Screws3 lb-ft4 Nm
Trunk/Liftgate Actuator2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Turn Signal Bulb - Front1 spec
- Connector Screws3 lb-ft4 Nm
Turn Signal Bulb - Rear1 spec
- Connector Screws3 lb-ft4 Nm
Turn Signal Switch5 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
- Steering Column Covers1.5 lb-ft2 Nm
- Switch Mounting Screws2 lb-ft3 Nm
Voltage Regulator3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Washer Pump2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Washer Reservoir3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Window Motor and Regulator - Front3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Window Motor and Regulator - Rear3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Wiper Linkage7 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Linkage Pivot Nuts9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Motor Mounting Bolts7 lb-ft10 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Wiper Motor - Front3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Wiper Motor - Rear2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Wiper Switch2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Connector Screws3 lb-ft4 Nm
Suspension
Ball Joint - Lower7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Ball Joint - Upper7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Ball Joints - Upper and Lower9 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutUse new cotter pin64.9 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Coil Spring - Front6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Coil Spring - Rear6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Coil Springs - Front Pair6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Coil Springs - Rear Pair6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Control Arm Bushing - Front Lower6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Control Arm Bushing - Front Upper6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Control Arm Bushing - Rear6 specs
- Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Front Struts - Pair6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Front Suspension Rebuild5 specs
- Ball Joint Pinch BoltUse new bolt if locknut style37 lb-ft50 Nm
- Lower Control Arm BoltsTorque at ride height81 lb-ft110 Nm
- Strut Top Mount Nuts18 lb-ft25 Nm
- Sway Bar End Link Nuts44 lb-ft60 Nm
- Upper Control Arm BoltsTorque at ride height66 lb-ft90 Nm
Knuckle/Spindle - Front8 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutUse new cotter pin64.9 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Knuckle/Spindle - Rear7 specs
- Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Lateral Arm5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Lower Control Arm - Front6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Lower Control Arm - Rear6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Radius Arm5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Radius Arm Bushing5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Rear Shocks - Pair5 specs
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Rear Suspension Service4 specs
- Lower Control Arm BoltsTorque at ride height66 lb-ft90 Nm
- Shock Lower Bolt52 lb-ft70 Nm
- Sway Bar End Link Nuts37 lb-ft50 Nm
- Trailing Arm BoltsTorque at ride height88 lb-ft120 Nm
Shock Absorber Replacement2 specs
- Lower Mount Bolt66 lb-ft90 Nm
- Upper Mount NutUse new self-locking nut41 lb-ft55 Nm
Strut Assembly - Front3 specs
- Strut Mount Center NutHold strut shaft with Allen key41 lb-ft55 Nm
- Strut Tower NutsDo not loosen center nut unless compressed37 lb-ft50 Nm
- Sway Bar End Link Nuts41 lb-ft55 Nm
Strut Assembly - Rear6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Strut Bearing6 specs
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Strut Mount - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Strut Mount - Rear6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Subframe6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Subframe Bushing6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar Bushing - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar Bushing - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar Link - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar Link - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Sway Bar Links - Front Pair5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Torsion Bar5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Torsion Bar Adjustment3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Trailing Arm5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Trailing Arm Bushing5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Upper Control Arm - Front7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Upper Control Arm - Rear5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Steering
Center Link/Drag Link7 specs
- Castle NutsUse new cotter pins41 lb-ft55 Nm
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Electric Power Steering Module5 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Electric Power Steering Motor6 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Idler Arm8 specs
- Coupling Bolt25 lb-ft34 Nm
- Idler Arm Bolts55 lb-ft75 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Castle Nut41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Pitman Arm7 specs
- Coupling Bolt25 lb-ft34 Nm
- Pitman Arm NutUse puller for removal136 lb-ft185 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Fluid Flush7 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Gear Box9 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings. Verify sequence with the service manual22 lb-ft30 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin. Verify sequence with the service manual41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Hose - High Pressure6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Hose - Return6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Pump11 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings. Verify sequence with the service manual22 lb-ft30 Nm
- Power Steering Pump BoltsVerify sequence with the service manual18 lb-ft25 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Return Line ClampVerify sequence with the service manual3 lb-ft4 Nm
- Serpentine Belt TensionerVerify sequence with the service manual41 lb-ft55 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Pump Pulley6 specs
- Coupling Bolt25 lb-ft34 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Rack9 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings. Verify sequence with the service manual22 lb-ft30 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin. Verify sequence with the service manual41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Power Steering Reservoir5 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Rack and Pinion Boots5 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Angle Sensor4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Column9 specs
- Coupling Bolt25 lb-ft34 Nm
- Ignition Switch BoltsVerify sequence with the service manual4 lb-ft5 Nm
- Pinch BoltVerify sequence with the service manual22 lb-ft30 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Column BoltsVerify sequence with the service manual22 lb-ft30 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Coupler5 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Damper4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Shaft - Intermediate5 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Shaft - Upper4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Steering Wheel8 specs
- Airbag Module BoltsTorx - usually T30. Verify sequence with the service manual5 lb-ft7 Nm
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Steering Wheel NutVerify sequence with the service manual40 lb-ft54 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Tie Rod Assembly6 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Tie Rod End - Inner7 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Tie Rod End - Outer6 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Tie Rods - Both Sides6 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Drivetrain
Axle Seal - Front6 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Axle Seal - Rear6 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
CV Axle - Front9 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- Ball Joint Pinch Bolt41 lb-ft55 Nm
- CV Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
CV Axle - Rear8 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- Ball Joint Nut75 lb-ft102 Nm
- CV Axle Nut148 lb-ft200 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
CV Axles - Front Pair6 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
CV Boot - Inner5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
CV Boot - Outer5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Differential Fluid Change - Front4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Differential Fluid Change - Rear4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Driveshaft - Front5 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Driveshaft - Rear7 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Yoke Pinion NutMark position before removal148 lb-ft200 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft Center Support26 lb-ft35 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Driveshaft Center Support Bearing5 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Front Differential7 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Limited Slip Clutch Pack7 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Locking Hub - Auto5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Locking Hub - Manual5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Rear Differential7 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Transfer Case8 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft Flange Bolts15 lb-ft20 Nm
- Transfer Case Bolts26 lb-ft35 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
Transfer Case Fluid Change11 specs
- Air Box Clips4 lb-ft5 Nm
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- Connector Bolts5 lb-ft7 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Transfer Case Drain Plug18 lb-ft25 Nm
- Transfer Case Fill Plug18 lb-ft25 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
U-Joint8 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug Nuts129 lb-ft175 Nm
- Yoke NutIf equipped111 lb-ft150 Nm
Wheel Bearing - Press-In Front6 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Wheel Bearing - Press-In Rear7 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Wheel Bearing Hub - Front4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Axle NutUse new cotter pin after torque184 lb-ft250 Nm
- Caliper Bracket Bolts88 lb-ft120 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified81 lb-ft110 Nm
Wheel Bearing Hub - Rear3 specs
- Axle NutUse new cotter pin after torque148 lb-ft200 Nm
- Caliper Bracket Bolts81 lb-ft110 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified74 lb-ft100 Nm
Wheel Studs5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern129 lb-ft175 Nm
Transmission
Clutch Hydraulic Line4 specs
- Bell Housing Bolts35 lb-ft47 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Pressure Plate BoltStar pattern20 lb-ft27 Nm
Dual Mass Flywheel4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Manual Trans Fluid Change3 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Neutral Safety Switch3 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Switch Mounting Bolts11 lb-ft15 Nm
Overdrive Solenoid4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Pressure Plate4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Shift Cable4 specs
- Adjustment Nut7 lb-ft10 Nm
- Cable Bracket Bolts11 lb-ft15 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Shift Fork3 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Shift Linkage4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Linkage Bolts11 lb-ft15 Nm
- Pivot Bolts9 lb-ft12 Nm
Shift Solenoid - Single4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Shift Solenoids - All4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Synchros - All4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Synchros - Single Gear3 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Torque Converter4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Torque Converter BoltsTighten evenly37 lb-ft50 Nm
Torque Converter Clutch Solenoid4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Control Module4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Cooler Lines2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Filter4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Filter and Fluid4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Fluid Change4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Flush4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Input Shaft Bearing5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Oil Cooler9 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fan Bolts8 lb-ft11 Nm
- Fill Plug25 lb-ft34 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Transmission Output Shaft Bearing5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Pan Gasket4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission R&R - Automatic5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission R&R - Manual4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Transmission Range Sensor4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Rebuild - Automatic5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Rebuild - Manual5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Speed Sensor - Input3 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Speed Sensor - Output2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Valve Body4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Heating and A/C
AC Accumulator5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Clutch Coil4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Compressor3 specs
- AC Compressor Bolts18 lb-ft25 Nm
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Clutch Connector Bolt6 lb-ft8 Nm
AC Compressor Clutch4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Compressor Oil Add5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Condenser2 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Condenser Mounting Bolts9 lb-ft12 Nm
AC Evaporator7 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Evaporator Case Screws4 lb-ft5 Nm
- Expansion Valve7 lb-ft10 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Expansion Valve (TXV)6 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Expansion Valve7 lb-ft10 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC High Pressure Switch5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose - High Side5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose - Low Side6 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Hose Clamps2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose Assembly6 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Hose Clamps2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Low Pressure Switch5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Orifice Tube5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Pressure Sensor5 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Receiver/Drier6 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
- Receiver Drier Bolts7 lb-ft10 Nm
AC Recharge4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Blend Door Actuator5 specs
- Actuator Screws2 lb-ft3 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Cabin Air Filter4 specs
- Compressor Bolts25 lb-ft34 Nm
- Connector Bolts5 lb-ft7 Nm
- Filter Cover ClipsTool-free on most2 lb-ft3 Nm
- Glove Box Screws3 lb-ft4 Nm
Climate Control Module4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
HVAC Control Panel4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Mode Door Actuator4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Recirculation Door Actuator4 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Body
Bumper Cover - Front8 specs
- Bumper Cover Bolts7 lb-ft10 Nm
- Fender Liner Screws2 lb-ft3 Nm
- Grille Clips4 lb-ft5 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Cover - Rear7 specs
- Bumper Cover Bolts7 lb-ft10 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
- Trunk Liner Screws2 lb-ft3 Nm
Bumper Reinforcement - Front7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Reinforcement - Rear7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Check/Stop6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Glass5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Exterior7 specs
- Handle Mounting Bolts6 lb-ft8 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Lock Rod Clips4 lb-ft5 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Interior7 specs
- Cable Clips4 lb-ft5 Nm
- Handle Screws2 lb-ft3 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Hinge6 specs
- Door Hinge Bolts22 lb-ft30 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Shell7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Skin7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Weatherstrip5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender8 specs
- Fender Bolts9 lb-ft12 Nm
- Fender Liner Screws2 lb-ft3 Nm
- Hinge Bolts20 lb-ft27 Nm
- Hood Hinge Bolts18 lb-ft25 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender Liner7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Grille7 specs
- Clips4 lb-ft5 Nm
- Grille Mounting Screws2 lb-ft3 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood8 specs
- Hinge Bolts20 lb-ft27 Nm
- Hood Hinge Bolts18 lb-ft25 Nm
- Hood Latch Bolts9 lb-ft12 Nm
- Hood Strut Bolts7 lb-ft10 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Hinge6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Latch7 specs
- Cable Clips4 lb-ft5 Nm
- Hinge Bolts20 lb-ft27 Nm
- Hood Latch Bolts9 lb-ft12 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Release Cable7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Strut6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Glass6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Panel8 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Door Hinge Bolts22 lb-ft30 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Rear Window6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Side Mirror Glass5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Hinge7 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Latch6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Lid7 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
- Trunk Hinge Bolts18 lb-ft25 Nm
- Trunk Latch Bolts9 lb-ft12 Nm
Trunk Strut6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield6 specs
- Body Panel Bolts18 lb-ft25 Nm
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield Molding5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Interior
Armrest2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Carpet4 specs
- Connector Bolts5 lb-ft7 Nm
- Dashboard Screws2 lb-ft3 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Center Console3 specs
- Connector Bolts5 lb-ft7 Nm
- Console Screws2 lb-ft3 Nm
- Shifter Trim4 lb-ft5 Nm
Dash Pad4 specs
- Connector Bolts5 lb-ft7 Nm
- Dashboard Screws2 lb-ft3 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Dashboard4 specs
- Connector Bolts5 lb-ft7 Nm
- Dashboard Bolt9 lb-ft12 Nm
- Dashboard Screws2 lb-ft3 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Door Panel3 specs
- Connector Bolts5 lb-ft7 Nm
- Door Panel Screws1.5 lb-ft2 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Floor Mat Hooks2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Glove Box3 specs
- Connector Bolts5 lb-ft7 Nm
- Glove Box Screws2 lb-ft3 Nm
- Hinge Screws1.5 lb-ft2 Nm
Glove Box Latch3 specs
- Connector Bolts5 lb-ft7 Nm
- Dashboard Screws2 lb-ft3 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Headliner3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Pedal Pads2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Rearview Mirror2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat - Front4 specs
- Connector Bolts5 lb-ft7 Nm
- Electrical Connectors4 lb-ft5 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Seat Track Bolts33 lb-ft45 Nm
Seat - Rear3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Back Release11 lb-ft15 Nm
- Seat Mounting Bolts26 lb-ft35 Nm
Seat Belt3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Belt Buckle3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Belt Pretensioner3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Cover3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Foam3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Track3 specs
- Connector Bolts5 lb-ft7 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Shifter Boot2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Shifter Knob2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Steering Wheel Cover2 specs
- Connector Bolts5 lb-ft7 Nm
- Trim Panel ClipsReplace if damaged. Verify sequence with the service manual1.5 lb-ft2 Nm
Sun Visor2 specs
- Connector Bolts5 lb-ft7 Nm
- Visor Mounting Screws2 lb-ft3 Nm
EV battery
12V Auxiliary Battery1 spec
- Connector Bolts5 lb-ft7 Nm
Battery Cooling System Service7 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Disconnect Service5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Junction Box7 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Management System (BMS)6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Thermal Management Module6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
DC-DC Converter3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Battery Module R&R4 specs
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Battery Pack R&R3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV motor
Drive Unit Fluid Change1 spec
- Connector Bolts5 lb-ft7 Nm
Electric Drive Motor R&R3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Electric Motor Inspection2 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Inverter Coolant Service1 spec
- Connector Bolts5 lb-ft7 Nm
Inverter R&R3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Motor Mount - Electric3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Power Electronics Module3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Reduction Gear Service3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
EV charging
Charge Port Assembly3 specs
- Charging Port Mounting6 lb-ft8 Nm
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Charge Port Door Actuator2 specs
- Charging Port Mounting6 lb-ft8 Nm
- Connector Bolts5 lb-ft7 Nm
Charge Port Latch2 specs
- Charging Port Mounting6 lb-ft8 Nm
- Connector Bolts5 lb-ft7 Nm
Charge Port Seal2 specs
- Charging Port Mounting6 lb-ft8 Nm
- Connector Bolts5 lb-ft7 Nm
Charging Cable - Level 11 spec
- Connector Bolts5 lb-ft7 Nm
Charging Cable - Level 21 spec
- Connector Bolts5 lb-ft7 Nm
DC Fast Charge Port3 specs
- Charging Port Mounting6 lb-ft8 Nm
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Onboard Charger R&R2 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV cooling
Cabin Heater - PTC3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Chiller Unit3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Coolant Lines3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Coolant Pump3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Thermal Management System3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Valve Mounting7 lb-ft10 Nm
Heat Pump System3 specs
- Connector Bolts5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV electrical
EV System Reset/Calibration1 spec
- Connector Bolts5 lb-ft7 Nm
High Voltage Cable Inspection2 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Interlock Service3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
High Voltage Service Disconnect2 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Wiring Harness3 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Pyrotechnic Fuse Inspection2 specs
- Connector Bolts5 lb-ft7 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV brakes
Regenerative Braking Calibration1 spec
- Connector Bolts5 lb-ft7 Nm
EV service
EV Annual Inspection1 spec
- Connector Bolts5 lb-ft7 Nm
EV Cabin Filter (HEPA)2 specs
- Connector Bolts5 lb-ft7 Nm
- Module Mounting Bolts6 lb-ft8 Nm
EV Software Update1 spec
- Connector Bolts5 lb-ft7 Nm
Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.
Need labor times, fluids or repair steps for this car? See it on the Open Labor Project