RQUE SPECS2023 Rivian R1S torque specs
Max Pack Dual Motor AWD
Change vehicle
Most looked up
- Lug nuts103 lb-ft140 Nm
- Spark plugs15 lb-ft20 Nm
- Front caliper bracket bolts88 lb-ft120 Nm
- Rear caliper bracket bolts74 lb-ft100 Nm
- Front axle nut184 lb-ft250 Nm
- Outer tie rod end nut40 lb-ft54 Nm
Maintenance
AC System Diagnosis2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Battery Test4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Charging System Test1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Check Engine Light Diagnosis1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Cooling System Pressure Test1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Diagnostic Scan3 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Differential Service4 specs
- Drain PlugNew washer30 lb-ft41 Nm
- Fill Plug30 lb-ft41 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Drivability Diagnosis2 specs
- Air Box Clips4 lb-ft5 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Electrical Diagnosis1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Fluid Leak Diagnosis1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Noise Diagnosis1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Power Steering Service4 specs
- Air Box ClipsVerify sequence with the service manual4 lb-ft5 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Tire Balance1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Tire Mount and Balance1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Tire Rotation2 specs
- Lug Nuts - Alloy WheelsTorque in star pattern, recheck after 50 miles96 lb-ft130 Nm
- Lug Nuts - Steel WheelsTorque in star pattern103 lb-ft140 Nm
TPMS Relearn1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
TPMS Sensor1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Transmission Service1 spec
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Tune-Up - Major3 specs
- Air Box Clips4 lb-ft5 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Tune-Up - Minor3 specs
- Air Box Clips4 lb-ft5 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Wheel Alignment7 specs
- Air Box Clips4 lb-ft5 Nm
- Cam BoltsAfter adjustment95 lb-ft129 Nm
- Camber BoltsIf adjustable55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Tie Rod Jam Nuts41 lb-ft55 Nm
- Tie Rod Lock NutAfter adjustment50 lb-ft68 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brakes
ABS Module5 specs
- ABS Module Bolts7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Pump3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
ABS Tone Ring4 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
ABS Wheel Speed Sensor - Front5 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Bearing Hub Bolts81 lb-ft110 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Wheel Speed Sensor - Rear4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Bleed - All Four3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Booster6 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Booster NutsVerify sequence with the service manual18 lb-ft25 Nm
- Brake Pedal Pushrod LockVerify sequence with the service manual11 lb-ft15 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Master Cylinder NutsVerify sequence with the service manual18 lb-ft25 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Booster Check Valve2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Caliper - Front3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
Brake Caliper - Rear3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
Brake Caliper Bracket6 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Brake Hose Banjo BoltNew copper washers30 lb-ft41 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Caliper Rebuild - Front5 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brake Caliper Rebuild - Rear4 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brake Caliper Slide Pins4 specs
- Caliper Bracket Bolts - FrontThreadlocker recommended88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brake Drum - Rear2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Fluid Flush5 specs
- Air Box ClipsVerify sequence with the service manual4 lb-ft5 Nm
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Oil Drain PlugUse new crush washer. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Hose - Front5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers. Verify sequence with the service manual18 lb-ft25 Nm
- Brake Hose BracketVerify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Hose - Rear5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers. Verify sequence with the service manual18 lb-ft25 Nm
- Brake Hose BracketVerify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Light Switch2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Line - Single3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Lines - Complete Set3 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Master Cylinder2 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Nuts18 lb-ft25 Nm
Brake Master Cylinder Rebuild3 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Mounting Nuts18 lb-ft25 Nm
- Reservoir Mounting Bolts6 lb-ft8 Nm
Brake Pads - Front3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brake Pads - Rear3 specs
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
- Caliper Slide Pin BoltsApply silicone brake grease22 lb-ft30 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Brake Pads and Rotors - Front7 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Pads and Rotors - Rear6 specs
- Bleeder ScrewDo not overtighten. Verify sequence with the service manual7 lb-ft10 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Proportioning Valve5 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Line FittingsUse flare nut wrench. Verify sequence with the service manual11 lb-ft15 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Proportioning Valve BoltsVerify sequence with the service manual11 lb-ft15 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Rotor - Front Single7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Rotor - Rear Single6 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Rotors - Front Pair7 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontThreadlocker recommended. Verify sequence with the service manual88 lb-ft120 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Brake Rotors - Rear Pair6 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Drum Brake Hardware Kit2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Drum Brake Shoes - Rear2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Electronic Parking Brake Motor3 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Front Brake Pad Replacement3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Parking Brake Actuator3 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide Pin BoltsApply silicone brake grease. Verify sequence with the service manual26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Parking Brake Cable5 specs
- Bleeder Screw10 lb-ft14 Nm
- Cable Bracket BoltsVerify sequence with the service manual9 lb-ft12 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Equalizer NutAdjust for proper tension. Verify sequence with the service manual11 lb-ft15 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Parking Brake Shoes5 specs
- Adjuster LockVerify sequence with the service manual4 lb-ft5 Nm
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Hold-Down SpringsVerify sequence with the service manual6 lb-ft8 Nm
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
Wheel Cylinder3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Engine
Camshaft Position Sensor2 specs
- Camshaft Position Sensor7 lb-ft10 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Connecting Rod Bearings3 specs
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence9 lb-ft12 Nm
Crankshaft Position Sensor1 spec
- Crankshaft Position Sensor7 lb-ft10 Nm
Engine Mount - Front3 specs
- Engine Mount Through-Bolt63 lb-ft85 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
Engine R&R10 specs
- AC Compressor Bolts18 lb-ft25 Nm
- Alternator Mounting Bolts37 lb-ft50 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Power Steering Pump Bolts18 lb-ft25 Nm
- Starter Mounting Bolt37 lb-ft50 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Flywheel2 specs
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Flywheel BoltsOften TTY - check specs, tighten in star pattern70 lb-ft95 Nm
Freeze Plug - Single1 spec
- Freeze PlugUse sealant on edges7 lb-ft10 Nm
Freeze Plugs - All1 spec
- Freeze PlugUse sealant on edges7 lb-ft10 Nm
Front Main Seal5 specs
- Crankshaft Pulley BoltOften TTY, may need impact133 lb-ft180 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltFront section only9 lb-ft12 Nm
- Timing Cover Bolts - 10mmTighten in sequence33 lb-ft45 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
Harmonic Balancer1 spec
- Crankshaft Pulley BoltOften TTY - check spec, may require impact. Verify sequence with the service manual133 lb-ft180 Nm
Idle Air Control Valve1 spec
- IAC Valve Screws2 lb-ft3 Nm
Idler Pulley1 spec
- Idler Pulley Bolt33 lb-ft45 Nm
Knock Sensor1 spec
- Knock SensorTorque critical for function15 lb-ft20 Nm
Long Block Replacement13 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Cylinder Head BoltsTTY - tighten in sequence plus angle48 lb-ft65 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Intake Manifold Bolt18 lb-ft25 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Main Bearings6 specs
- Flywheel BoltsOften TTY, tighten in star pattern. Verify sequence with the service manual70 lb-ft95 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle. Verify sequence with the service manual55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer. Verify sequence with the service manual26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence. Verify sequence with the service manual9 lb-ft12 Nm
- Oil Pump Pickup TubeVerify sequence with the service manual9 lb-ft12 Nm
- Transmission-to-Engine BoltsVerify sequence with the service manual41 lb-ft55 Nm
Oil Level Sensor2 specs
- Oil Level Sensor11 lb-ft15 Nm
- Oil Pan BoltIf access needed9 lb-ft12 Nm
Oil Pan Replacement3 specs
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence9 lb-ft12 Nm
- Oil Pump Pickup Tube9 lb-ft12 Nm
Oil Pressure Sensor1 spec
- Oil Pressure SensorUse thread sealant15 lb-ft20 Nm
Oil Pump5 specs
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Oil Pump Bolts9 lb-ft12 Nm
- Oil Pump Pickup Tube9 lb-ft12 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
Rear Main Seal6 specs
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltRear section9 lb-ft12 Nm
- Rear Main Seal Housing9 lb-ft12 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Serpentine Belt2 specs
- Belt Tensioner Bolt41 lb-ft55 Nm
- Idler Pulley Bolt33 lb-ft45 Nm
Short Block Replacement9 specs
- Connecting Rod BoltsTTY - critical torque plus angle33 lb-ft45 Nm
- Crankshaft Pulley BoltOften TTY - check spec, may require impact133 lb-ft180 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Main Bearing Cap BoltsTTY - tighten in sequence plus angle55 lb-ft75 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan Bolt9 lb-ft12 Nm
- Oil Pump Bolts9 lb-ft12 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Transmission-to-Engine Bolts41 lb-ft55 Nm
Throttle Position Sensor1 spec
- TPS Screws2 lb-ft3 Nm
Transmission Mount5 specs
- Crossmember Bolt70 lb-ft95 Nm
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Mount Bolts48 lb-ft65 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Valve Job - Complete9 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Camshaft Sprocket BoltsHold cam with wrench on hex59 lb-ft80 Nm
- Cylinder Head BoltsTTY - tighten in sequence plus angle48 lb-ft65 Nm
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Intake Manifold Bolt18 lb-ft25 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Seals5 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Rocker Arm Shaft BoltsTighten evenly in sequence18 lb-ft25 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Spring - Single3 specs
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Springs - All5 specs
- Camshaft Cap BoltsTighten in sequence from center outward, multiple passes10 lb-ft14 Nm
- Rocker Arm BoltsTighten with cam lobe pointing away22 lb-ft30 Nm
- Rocker Arm Shaft BoltsTighten evenly in sequence18 lb-ft25 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Variable Valve Timing Actuator7 specs
- Cam Phaser BoltApply threadlocker, hold cam stationary48 lb-ft65 Nm
- Camshaft Sprocket BoltsHold cam with wrench on hex59 lb-ft80 Nm
- Crankshaft Pulley BoltOften TTY - check spec, may require impact133 lb-ft180 Nm
- Timing Chain Tensioner BoltInstall with pin/clip to compress18 lb-ft25 Nm
- Timing Cover Bolts - 8mmTighten in sequence18 lb-ft25 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
VVT Solenoid - Single2 specs
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
VVT Solenoids - All3 specs
- Camshaft Position Sensor7 lb-ft10 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
- VVT Solenoid Bolt7 lb-ft10 Nm
Cooling
Coolant Flush2 specs
- Block Drain PlugIf equipped, use new washer18 lb-ft25 Nm
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
Cooling Fan Assembly4 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Cooling Fan Clutch3 specs
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Cooling Fan Motor4 specs
- Electrical Connector4 lb-ft5 Nm
- Fan Motor Bolts6 lb-ft8 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Cooling Fan Relay2 specs
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Engine Oil Cooler4 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Heater Control Valve3 specs
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Valve Mounting6 lb-ft8 Nm
Heater Core5 specs
- Dashboard Screws2 lb-ft3 Nm
- Heater Core Mounting6 lb-ft8 Nm
- Heater Hose Clamps2 lb-ft3 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Heater Hoses4 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Radiator4 specs
- Drain PetcockPlastic - hand tight4 lb-ft5 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped18 lb-ft25 Nm
- Upper/Lower Hose Clamps2 lb-ft3 Nm
Radiator Removal and Service4 specs
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
- Fan Shroud Bolts7 lb-ft10 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped, use new washers18 lb-ft25 Nm
Thermostat2 specs
- Coolant Temperature SensorUse thread sealant15 lb-ft20 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Thermostat Housing3 specs
- Coolant Outlet/Housing BoltsTighten in sequence9 lb-ft12 Nm
- Coolant Temperature Sensor15 lb-ft20 Nm
- Hose ClampsSpring or constant-tension preferred2 lb-ft3 Nm
Water Pump3 specs
- Hose ClampsSpring clamps preferred2 lb-ft3 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Fuel system
Charcoal Canister2 specs
- Fuel Line FittingsUse new O-rings18 lb-ft25 Nm
- Hose Clamps2 lb-ft3 Nm
EVAP Purge Valve1 spec
- Hose Clamps2 lb-ft3 Nm
EVAP Vent Valve1 spec
- Hose Clamps2 lb-ft3 Nm
Fuel Filter2 specs
- Fuel Filter Bracket Bolt7 lb-ft10 Nm
- Fuel Line FittingsIf threaded type18 lb-ft25 Nm
Electrical
Airbag - Driver2 specs
- Airbag Module BoltsTorx - disconnect battery and wait 2 minutes5 lb-ft7 Nm
- Steering Wheel Nut40 lb-ft54 Nm
Airbag - Passenger2 specs
- Airbag Module BoltsTorx - disconnect battery and wait 2 minutes5 lb-ft7 Nm
- Dashboard Fasteners3 lb-ft4 Nm
Airbag - Side2 specs
- Seat Mounting BoltsSafety critical45 lb-ft61 Nm
- Side Airbag Module BoltsTorx5 lb-ft7 Nm
Airbag Module/Computer3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Alternator4 specs
- Alternator Mounting Bolts37 lb-ft50 Nm
- Alternator Pivot Bolt18 lb-ft25 Nm
- Battery Terminal BoltsDo not overtighten6 lb-ft8 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Amplifier3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Antenna1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Backup Camera3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery3 specs
- Battery Hold-Down Bolt6 lb-ft8 Nm
- Battery Terminal BoltsDo not overtighten - can crack terminal4 lb-ft6 Nm
- Battery Tray Bolts9 lb-ft12 Nm
Battery Cable - Negative5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery Cable - Positive4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Battery Cables - Both5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Battery Terminal5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Blower Motor2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Blower Motor Resistor Screws1.5 lb-ft2 Nm
Blower Motor Control Module2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Blower Motor Resistor1 spec
- Resistor Screws1.5 lb-ft2 Nm
Clock Spring4 specs
- Airbag Module BoltsTorx - disconnect battery first5 lb-ft7 Nm
- Clock Spring ScrewsAlign marks before removal3 lb-ft4 Nm
- Steering Column CoversPlastic clips2 lb-ft3 Nm
- Steering Wheel Nut40 lb-ft54 Nm
Combination Switch3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Dimmer Switch2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Door Lock Actuator - Front1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Door Lock Actuator - Rear1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Fog Light Assembly1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Fuse Box - Engine Bay3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Fuse Box - Interior3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Headlight Assembly2 specs
- Adjuster Screws2 lb-ft3 Nm
- Headlight Assembly Bolts7 lb-ft10 Nm
Headlight Bulb - Single1 spec
- Bulb Retaining Ring4 lb-ft5 Nm
Headlight Switch2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Heated Seat Module2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
HID Ballast2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Horn1 spec
- Horn Mounting Bolt11 lb-ft15 Nm
Horn Relay1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Instrument Cluster2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
LED Headlight Module2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Main Relay2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Antenna Motor1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Power Mirror Motor1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Power Seat Motor2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Motor - Front2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Motor - Rear2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Regulator - Front2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Power Window Regulator - Rear1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Radio/Head Unit2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Relay - Generic2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Seat Heater Element3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Side Mirror Assembly1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Speaker - Dash2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Speaker - Door1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Speedometer3 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Starter3 specs
- Heat Shield BoltsIf equipped7 lb-ft10 Nm
- Starter Mounting BoltLong bolt may need extension37 lb-ft50 Nm
- Starter Solenoid NutFor B+ cable9 lb-ft12 Nm
Starter Solenoid3 specs
- Battery Cable Nut10 lb-ft14 Nm
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Starter Mounting Bolt35 lb-ft47 Nm
Subwoofer2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Sunroof Motor2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Sunroof Switch1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Tail Light Assembly2 specs
- Lens Screws1.5 lb-ft2 Nm
- Tail Light Bolts6 lb-ft8 Nm
Trunk/Liftgate Actuator1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Turn Signal Switch2 specs
- Steering Column Covers1.5 lb-ft2 Nm
- Switch Mounting Screws2 lb-ft3 Nm
Voltage Regulator2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Washer Pump1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Washer Reservoir2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Window Motor and Regulator - Front2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Window Motor and Regulator - Rear2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Wiper Linkage6 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Ground Strap BoltsEnsure clean contact9 lb-ft12 Nm
- Linkage Pivot Nuts9 lb-ft12 Nm
- Module Mounting Bolts6 lb-ft8 Nm
- Motor Mounting Bolts7 lb-ft10 Nm
- Sensor Mounting Bolts7 lb-ft10 Nm
Wiper Motor - Front2 specs
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Wiper Motor - Rear1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Wiper Switch1 spec
- Battery Terminal BoltsDo not overtighten4 lb-ft6 Nm
Suspension
Air Line2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Air Spring/Air Bag5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Air Suspension Compressor2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Air Suspension Height Sensor2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Air Suspension Valve Block2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Ball Joint - Lower5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Ball Joint - Upper5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint Nut65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Ball Joints - Upper and Lower7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint NutNew cotter pin64.9 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Spring - Front5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Spring - Rear5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Springs - Front Pair5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Springs - Rear Pair5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Control Arm Bushing - Front Lower4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Control Arm Bushing - Front Upper4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint Nut65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Control Arm Bushing - Rear4 specs
- Ball Joint NutNew cotter pin65 lb-ft88 Nm
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Front Struts - Pair7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Front Suspension Rebuild5 specs
- Ball Joint Pinch BoltUse new bolt if locknut style37 lb-ft50 Nm
- Lower Control Arm BoltsTorque at ride height81 lb-ft110 Nm
- Strut Top Mount Nuts18 lb-ft25 Nm
- Sway Bar End Link Nuts44 lb-ft60 Nm
- Upper Control Arm BoltsTorque at ride height66 lb-ft90 Nm
Knuckle/Spindle - Front7 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint Nut64.9 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Knuckle/Spindle - Rear6 specs
- Ball Joint Nut65 lb-ft88 Nm
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Lateral Arm4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Lower Control Arm - Front5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Lower Control Arm - Rear5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Radius Arm4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Radius Arm Bushing4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Rear Shocks - Pair4 specs
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Rear Suspension Service4 specs
- Lower Control Arm BoltsTorque at ride height66 lb-ft90 Nm
- Shock Lower Bolt52 lb-ft70 Nm
- Sway Bar End Link Nuts37 lb-ft50 Nm
- Trailing Arm BoltsTorque at ride height88 lb-ft120 Nm
Shock Absorber Replacement2 specs
- Lower Mount Bolt66 lb-ft90 Nm
- Upper Mount NutUse new self-locking nut41 lb-ft55 Nm
Strut Assembly - Rear5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Bearing5 specs
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Mount - Front5 specs
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Mount - Rear5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Subframe5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Subframe Bushing5 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Sway Bar - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar - Rear3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar Bushing - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar Bushing - Rear3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar Link - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar Link - Rear3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Sway Bar Links - Front Pair3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
Torsion Bar4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Torsion Bar Adjustment2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Trailing Arm4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Trailing Arm Bushing4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Upper Control Arm - Front6 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut Tower Nuts37 lb-ft50 Nm
- Sway Bar Link NutsHold shaft with Allen key41 lb-ft55 Nm
- Upper Ball Joint Nut65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Upper Control Arm - Rear4 specs
- Control Arm BoltsTorque with vehicle weight on wheels122 lb-ft165 Nm
- Strut Bolts85 lb-ft115 Nm
- Upper Ball Joint Nut65 lb-ft88 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering
Center Link/Drag Link4 specs
- Castle NutsUse new cotter pins41 lb-ft55 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Electric Power Steering Module3 specs
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Electric Power Steering Motor4 specs
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Idler Arm5 specs
- Idler Arm Bolts55 lb-ft75 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Castle Nut41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Pitman Arm4 specs
- Pitman Arm NutUse puller for removal136 lb-ft185 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Fluid Flush5 specs
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Gear Box7 specs
- Power Steering Line FittingsUse new O-rings. Verify sequence with the service manual22 lb-ft30 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin. Verify sequence with the service manual41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Hose - High Pressure4 specs
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Hose - Return4 specs
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Pump4 specs
- Power Steering Pump Bolts18 lb-ft25 Nm
- Pressure Line FittingUse new O-rings22 lb-ft30 Nm
- Return Line Clamp3 lb-ft4 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Power Steering Pump Pulley4 specs
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Rack7 specs
- Power Steering Line FittingsUse new O-rings. Verify sequence with the service manual22 lb-ft30 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin. Verify sequence with the service manual41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Reservoir3 specs
- Power Steering Line FittingsUse new O-rings22 lb-ft30 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Rack and Pinion Boots3 specs
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Angle Sensor2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Column6 specs
- Ignition Switch BoltsVerify sequence with the service manual4 lb-ft5 Nm
- Pinch BoltVerify sequence with the service manual22 lb-ft30 Nm
- Steering Column BoltsVerify sequence with the service manual22 lb-ft30 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Coupler3 specs
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Damper2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Shaft - Intermediate3 specs
- Steering Rack BoltsVerify sequence with the service manual74 lb-ft100 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Shaft - Upper2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Wheel5 specs
- Airbag Module BoltsTorx - usually T30. Verify sequence with the service manual5 lb-ft7 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Steering Wheel NutVerify sequence with the service manual40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod Assembly5 specs
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod End - Inner6 specs
- Steering Rack Bolts74 lb-ft100 Nm
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod End - Outer5 specs
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rods - Both Sides5 specs
- Tie Rod End Castle NutUse new cotter pin41 lb-ft55 Nm
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Drivetrain
Axle Seal - Front4 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Axle Seal - Rear4 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
CV Axle - Front6 specs
- Axle Nut180 lb-ft244 Nm
- Ball Joint Pinch Bolt41 lb-ft55 Nm
- CV Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Axle - Rear5 specs
- Axle NutNew nut, stake180 lb-ft244 Nm
- Ball Joint Nut75 lb-ft102 Nm
- CV Axle Nut148 lb-ft200 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Axles - Front Pair4 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
CV Boot - Inner3 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
CV Boot - Outer3 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Differential Fluid Change - Front3 specs
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Differential Fluid Change - Rear3 specs
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Driveshaft - Front3 specs
- CV Bolts45 lb-ft61 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Driveshaft - Rear5 specs
- CV Bolts45 lb-ft61 Nm
- Differential Yoke Pinion NutMark position before removal148 lb-ft200 Nm
- Driveshaft Center Support26 lb-ft35 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Driveshaft Center Support Bearing3 specs
- CV Bolts45 lb-ft61 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Front Differential5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Limited Slip Clutch Pack5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Locking Hub - Auto3 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Locking Hub - Manual3 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Rear Differential5 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Transfer Case5 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Driveshaft Flange Bolts15 lb-ft20 Nm
- Transfer Case Bolts26 lb-ft35 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Transfer Case Fluid Change5 specs
- Air Box Clips4 lb-ft5 Nm
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Transfer Case Drain Plug18 lb-ft25 Nm
- Transfer Case Fill Plug18 lb-ft25 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
U-Joint5 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Driveshaft U-Joint StrapsTighten evenly15 lb-ft20 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
- Yoke NutIf equipped111 lb-ft150 Nm
Wheel Bearing - Press-In Front4 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Wheel Bearing - Press-In Rear5 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- Differential Cover Bolts26 lb-ft35 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Wheel Bearing Hub - Front4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Axle NutUse new cotter pin after torque184 lb-ft250 Nm
- Caliper Bracket Bolts88 lb-ft120 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified81 lb-ft110 Nm
Wheel Bearing Hub - Rear3 specs
- Axle NutUse new cotter pin after torque148 lb-ft200 Nm
- Caliper Bracket Bolts81 lb-ft110 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified74 lb-ft100 Nm
Wheel Studs3 specs
- Axle NutUse new cotter pin or stake nut184 lb-ft250 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern103 lb-ft140 Nm
Transmission
Clutch Hydraulic Line2 specs
- Bell Housing Bolts35 lb-ft47 Nm
- Pressure Plate BoltStar pattern20 lb-ft27 Nm
Dual Mass Flywheel2 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Manual Trans Fluid Change1 spec
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Neutral Safety Switch1 spec
- Switch Mounting Bolts11 lb-ft15 Nm
Overdrive Solenoid2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Pressure Plate2 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Shift Cable2 specs
- Adjustment Nut7 lb-ft10 Nm
- Cable Bracket Bolts11 lb-ft15 Nm
Shift Fork1 spec
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Shift Linkage2 specs
- Linkage Bolts11 lb-ft15 Nm
- Pivot Bolts9 lb-ft12 Nm
Shift Solenoid - Single2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Shift Solenoids - All2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Synchros - All2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Synchros - Single Gear1 spec
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Torque Converter2 specs
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Torque Converter BoltsTighten evenly37 lb-ft50 Nm
Torque Converter Clutch Solenoid2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Control Module2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Filter2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Filter and Fluid2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Fluid Change3 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Filter BoltsIf equipped with bolted filter6 lb-ft8 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Flush2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Input Shaft Bearing3 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Oil Cooler5 specs
- Coolant Drain Plug11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Transmission Output Shaft Bearing3 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Pan Gasket2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission R&R - Automatic3 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission R&R - Manual2 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
Transmission Range Sensor2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Rebuild - Automatic3 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Rebuild - Manual3 specs
- Flywheel BoltsOften TTY, tighten in star pattern70 lb-ft95 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Speed Sensor - Input1 spec
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Valve Body2 specs
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Exhaust
Muffler2 specs
- Hanger Bracket Bolts18 lb-ft25 Nm
- Muffler Clamps41 lb-ft55 Nm
Heating and A/C
AC Accumulator3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Clutch Coil2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Compressor3 specs
- AC Compressor Bolts18 lb-ft25 Nm
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Clutch Connector Bolt6 lb-ft8 Nm
AC Compressor Clutch2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Compressor Oil Add3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Condenser2 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Condenser Mounting Bolts9 lb-ft12 Nm
AC Evaporator4 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
- Evaporator Case Screws4 lb-ft5 Nm
- Expansion Valve7 lb-ft10 Nm
AC Expansion Valve (TXV)3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
- Expansion Valve7 lb-ft10 Nm
AC High Pressure Switch3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Hose - High Side3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Hose - Low Side4 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Hose Clamps2 lb-ft3 Nm
AC Hose Assembly4 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Hose Clamps2 lb-ft3 Nm
AC Low Pressure Switch3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Orifice Tube3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Pressure Sensor3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Receiver/Drier3 specs
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
- Receiver Drier Bolts7 lb-ft10 Nm
AC Recharge2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
Blend Door Actuator2 specs
- Actuator Screws2 lb-ft3 Nm
- Compressor Bolts25 lb-ft34 Nm
Cabin Air Filter2 specs
- Compressor Bolts25 lb-ft34 Nm
- Filter Cover Clips4 lb-ft5 Nm
Climate Control Module2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
HVAC Control Panel2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
Mode Door Actuator2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
Recirculation Door Actuator2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
Body
Bumper Cover - Front3 specs
- Bumper Cover Bolts7 lb-ft10 Nm
- Fender Liner Screws2 lb-ft3 Nm
- Grille Clips4 lb-ft5 Nm
Bumper Cover - Rear2 specs
- Bumper Cover Bolts7 lb-ft10 Nm
- Trunk Liner Screws2 lb-ft3 Nm
Bumper Reinforcement - Front2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
Bumper Reinforcement - Rear2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
Door Check/Stop1 spec
- Body Panel Bolts18 lb-ft25 Nm
Door Handle - Exterior2 specs
- Handle Mounting Bolts6 lb-ft8 Nm
- Lock Rod Clips4 lb-ft5 Nm
Door Handle - Interior2 specs
- Cable Clips4 lb-ft5 Nm
- Handle Screws2 lb-ft3 Nm
Door Hinge1 spec
- Door Hinge Bolts22 lb-ft30 Nm
Door Shell2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
Door Skin2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
Fender3 specs
- Fender Bolts9 lb-ft12 Nm
- Fender Liner Screws2 lb-ft3 Nm
- Hood Hinge Bolts18 lb-ft25 Nm
Fender Liner2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
Grille2 specs
- Clips4 lb-ft5 Nm
- Grille Mounting Screws2 lb-ft3 Nm
Hood3 specs
- Hood Hinge Bolts18 lb-ft25 Nm
- Hood Latch Bolts9 lb-ft12 Nm
- Hood Strut Bolts7 lb-ft10 Nm
Hood Hinge1 spec
- Body Panel Bolts18 lb-ft25 Nm
Hood Latch2 specs
- Cable Clips4 lb-ft5 Nm
- Hood Latch Bolts9 lb-ft12 Nm
Hood Release Cable2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
Hood Strut1 spec
- Body Panel Bolts18 lb-ft25 Nm
Liftgate2 specs
- Body Panel Bolts18 lb-ft25 Nm
- Door Hinge Bolts22 lb-ft30 Nm
Liftgate Motor1 spec
- Body Panel Bolts18 lb-ft25 Nm
Liftgate Strut1 spec
- Body Panel Bolts18 lb-ft25 Nm
Quarter Glass1 spec
- Body Panel Bolts18 lb-ft25 Nm
Quarter Panel3 specs
- Body Panel Bolts18 lb-ft25 Nm
- Bumper Cover Bolts7 lb-ft10 Nm
- Door Hinge Bolts22 lb-ft30 Nm
Rear Window1 spec
- Body Panel Bolts18 lb-ft25 Nm
Windshield1 spec
- Body Panel Bolts18 lb-ft25 Nm
Interior
Armrest1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Carpet3 specs
- Dashboard Screws2 lb-ft3 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Center Console2 specs
- Console Screws2 lb-ft3 Nm
- Shifter Trim4 lb-ft5 Nm
Dash Pad3 specs
- Dashboard Screws2 lb-ft3 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Dashboard3 specs
- Dashboard Bolt9 lb-ft12 Nm
- Dashboard Screws2 lb-ft3 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Door Panel2 specs
- Door Panel Screws1.5 lb-ft2 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Floor Mat Hooks1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Glove Box2 specs
- Glove Box Screws2 lb-ft3 Nm
- Hinge Screws1.5 lb-ft2 Nm
Glove Box Latch2 specs
- Dashboard Screws2 lb-ft3 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Headliner2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Pedal Pads1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Rearview Mirror1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat - Front3 specs
- Electrical Connectors4 lb-ft5 Nm
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Seat Track Bolts33 lb-ft45 Nm
Seat - Rear2 specs
- Seat Back Release11 lb-ft15 Nm
- Seat Mounting Bolts26 lb-ft35 Nm
Seat Belt2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Belt Buckle2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Belt Pretensioner2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Cover2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Foam2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Seat Track2 specs
- Seat Mounting BoltsSafety critical33 lb-ft45 Nm
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Shifter Boot1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Shifter Knob1 spec
- Trim Panel ClipsReplace if damaged1.5 lb-ft2 Nm
Steering Wheel Cover1 spec
- Trim Panel ClipsReplace if damaged. Verify sequence with the service manual1.5 lb-ft2 Nm
Sun Visor1 spec
- Visor Mounting Screws2 lb-ft3 Nm
EV battery
Battery Cooling System Service6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Disconnect Service4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Junction Box6 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Management System (BMS)5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Battery Thermal Management Module5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
DC-DC Converter2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Battery Module R&R3 specs
- Battery Module BoltsFollow service manual sequence18 lb-ft25 Nm
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Battery Pack R&R2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV motor
Electric Drive Motor R&R2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Electric Motor Inspection1 spec
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Inverter R&R2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Motor Mount - Electric2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Power Electronics Module2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
Reduction Gear Service2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Motor Mount Bolts55 lb-ft75 Nm
EV charging
Charge Port Assembly2 specs
- Charging Port Mounting6 lb-ft8 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Charge Port Door Actuator1 spec
- Charging Port Mounting6 lb-ft8 Nm
Charge Port Latch1 spec
- Charging Port Mounting6 lb-ft8 Nm
Charge Port Seal1 spec
- Charging Port Mounting6 lb-ft8 Nm
DC Fast Charge Port2 specs
- Charging Port Mounting6 lb-ft8 Nm
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
Onboard Charger R&R1 spec
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV cooling
Cabin Heater - PTC2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Chiller Unit2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Coolant Lines2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Coolant Pump2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV Thermal Management System2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Valve Mounting7 lb-ft10 Nm
Heat Pump System2 specs
- Coolant Line Fittings11 lb-ft15 Nm
- Hose Clamps2 lb-ft3 Nm
EV electrical
High Voltage Cable Inspection1 spec
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Interlock Service2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
High Voltage Service Disconnect1 spec
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
High Voltage Wiring Harness2 specs
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
- Module Mounting Bolts6 lb-ft8 Nm
Pyrotechnic Fuse Inspection1 spec
- High-Voltage Connector BoltsDe-energize system first7 lb-ft10 Nm
EV brakes
Regenerative Braking Calibration1 spec
- Wheel Lug NutsTorque in star pattern. Verify sequence with the service manual103 lb-ft140 Nm
EV service
EV Cabin Filter (HEPA)1 spec
- Module Mounting Bolts6 lb-ft8 Nm
Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.
Need labor times, fluids or repair steps for this car? See it on the Open Labor Project