1994 Pontiac Trans Sport torque specs

3.8L V6

Change vehicle

Most looked up

Lug nuts100 lb-ft136 Nm
Oil drain plug25 lb-ft34 Nm
Spark plugs16 lb-ft22 Nm
Front caliper bracket bolts74 lb-ft100 Nm
Rear caliper bracket bolts61 lb-ft83 Nm
Front axle nut192 lb-ft260 Nm
Outer tie rod end nut35 lb-ft47 Nm

Maintenance

AC System Diagnosis1 spec
- AC Line FittingsNew O-rings17 lb-ft23 Nm
Air Filter2 specs
- MAF Sensor Screws3 lb-ft5 Nm
- Mass Air Flow Sensor Screws2 lb-ft3 Nm
Battery Test3 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
Differential Service2 specs
- Drain PlugNew washer35 lb-ft47 Nm
- Fill Plug35 lb-ft47 Nm
Power Steering Service2 specs
- Pressure Line FittingNew O-ring29 lb-ft39 Nm
- Pump Mounting Bolts23 lb-ft31 Nm
Tire Rotation1 spec
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Wheel Alignment2 specs
- Cam BoltsAfter adjustment105 lb-ft142 Nm
- Tie Rod Lock NutAfter adjustment55 lb-ft75 Nm

Brakes

ABS Module3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Pump3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Tone Ring2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Wheel Speed Sensor - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
ABS Wheel Speed Sensor - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Bleed - All Four3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Booster3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Booster Check Valve1 spec
- Caliper Mounting Bolts75 lb-ft101 Nm
Brake Caliper - Front4 specs
- Bleeder Screw11 lb-ft15 Nm
- Brake Hose Banjo BoltUse new copper washers33 lb-ft45 Nm
- Caliper Mounting BoltsUse new bolts if specified74 lb-ft100 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Caliper - Rear4 specs
- Bleeder Screw11 lb-ft15 Nm
- Brake Hose Banjo BoltUse new copper washers28 lb-ft38 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Caliper Bracket4 specs
- Bleeder Screw12 lb-ft16 Nm
- Brake Hose Banjo BoltNew copper washers35 lb-ft47 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Caliper Rebuild - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Caliper Rebuild - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Caliper Slide Pins2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Drum - Rear2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Fluid Flush3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Hose - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Hose - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Light Switch1 spec
- Caliper Mounting Bolts75 lb-ft101 Nm
Brake Line - Single3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Lines - Complete Set3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Master Cylinder7 specs
- Bleeder Screw12 lb-ft16 Nm
- Brake Line FittingsUse line wrench16 lb-ft22 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Master Cylinder NutsTorque evenly22 lb-ft30 Nm
- Proportioning Valve Bolts20 lb-ft27 Nm
- Reservoir CapHand tight3 lb-ft4 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Pads - Front7 specs
- Bleeder ScrewCopper washer recommended11 lb-ft15 Nm
- Caliper Bracket BoltsUse thread locker74 lb-ft100 Nm
- Caliper Bracket Bolts - FrontTorque to spec, use thread locker74 lb-ft100 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Caliper Slide BoltsLubricate pins29 lb-ft39 Nm
- Caliper Slide Pin BoltsLubricate pins before install28 lb-ft38 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Pads - Rear6 specs
- Bleeder ScrewCopper washer recommended11 lb-ft15 Nm
- Caliper Bracket Bolts - RearTorque to spec, use thread locker61 lb-ft83 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Caliper Slide Pin BoltsLubricate pins before install28 lb-ft38 Nm
- Parking Brake AdjusterAdjust after pad install9 lb-ft12 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Pads and Rotors - Front5 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Bracket BoltsUse thread locker74 lb-ft100 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Caliper Slide BoltsLubricate pins29 lb-ft39 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Pads and Rotors - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Proportioning Valve3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Brake Rotor - Front Single5 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts74 lb-ft100 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Hub NutIf removed192 lb-ft260 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Rotor - Rear Single3 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Rotors - Front Pair5 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts74 lb-ft100 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Hub NutIf removed192 lb-ft260 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Brake Rotors - Rear Pair3 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug NutsTorque in star pattern100 lb-ft136 Nm
Drum Brake Hardware Kit2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Drum Brake Shoes - Rear2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Electronic Parking Brake Motor2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Parking Brake Actuator2 specs
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Parking Brake Cable3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Parking Brake Shoes3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Cylinder3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting Bolts75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm

Engine

Engine Mount - Front2 specs
- Engine Mount Through-Bolt75 lb-ft101 Nm
- Engine Mount-to-Frame Bolts52 lb-ft70 Nm
Engine Mount - Rear2 specs
- Engine Mount Through-Bolt75 lb-ft101 Nm
- Engine Mount-to-Frame Bolts52 lb-ft70 Nm
Engine Mounts - All2 specs
- Engine Mount Through-Bolt75 lb-ft101 Nm
- Engine Mount-to-Frame Bolts52 lb-ft70 Nm
Exhaust Manifold5 specs
- EGR Tube Fitting38 lb-ft52 Nm
- Exhaust Manifold NutsApply anti-seize28 lb-ft38 Nm
- Hanger Bolts17 lb-ft23 Nm
- Heat Shield Bolts11 lb-ft15 Nm
- O2 SensorApply anti-seize to threads38 lb-ft52 Nm
Exhaust Manifold Gasket2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 SensorAnti-seize threads40 lb-ft55 Nm
Head Gasket - Single5 specs
- Camshaft Cap BoltsTorque sequence14 lb-ft19 Nm
- Cylinder Head BoltsMulti-step + angle75 lb-ft101 Nm
- Exhaust Manifold Nuts29 lb-ft39 Nm
- Intake Manifold Bolt21 lb-ft28 Nm
- Valve Cover Bolts12 lb-ft16 Nm
Head Gaskets - Both5 specs
- Camshaft Cap BoltsTorque sequence14 lb-ft19 Nm
- Cylinder Head BoltsMulti-step + angle75 lb-ft101 Nm
- Exhaust Manifold Nuts29 lb-ft39 Nm
- Intake Manifold Bolt21 lb-ft28 Nm
- Valve Cover Bolts12 lb-ft16 Nm
Intake Manifold3 specs
- Fuel Rail Bolts17 lb-ft23 Nm
- Intake Manifold BoltTorque sequence21 lb-ft28 Nm
- Throttle Body Bolts12 lb-ft16 Nm
Intake Manifold Gasket4 specs
- Fuel Rail Bolts16 lb-ft22 Nm
- Intake Manifold BoltTorque in sequence20 lb-ft27 Nm
- PCV Valve Fitting9 lb-ft12 Nm
- Throttle Body Bolts11 lb-ft15 Nm
Oil Change3 specs
- Oil Drain PlugUse new washer each time25 lb-ft34 Nm
- Oil Filler CapHand tight6 lb-ft8 Nm
- Oil FilterHand tight + 3/4 turn20 lb-ft27 Nm
Oil Pan Gasket4 specs
- Oil Drain PlugUse new washer28 lb-ft38 Nm
- Oil Level Sensor11 lb-ft15 Nm
- Oil Pan BoltTorque in sequence13 lb-ft18 Nm
- Oil Pickup Tube BoltsCheck O-ring16 lb-ft22 Nm
Throttle Body4 specs
- Air Intake Hose Clamp3 lb-ft5 Nm
- Air Intake Hose Clamps3 lb-ft4 Nm
- Coolant Hose ClampsIf coolant heated3 lb-ft4 Nm
- Throttle Body Bolts11 lb-ft15 Nm
Timing Chain4 specs
- Camshaft Sprocket Bolts75 lb-ft102 Nm
- Crankshaft balancer bolt110 lb-ft149 Nm
- Timing chain front cover bolts10 lb-ft14 Nm
- Water pump to timing cover bolts9 lb-ft13 Nm
Timing Chain Guide5 specs
- Camshaft Sprocket Bolts63 lb-ft86 Nm
- Crankshaft Pulley Bolt150 lb-ft203 Nm
- Guide Bolts21 lb-ft28 Nm
- Tensioner Bolt17 lb-ft23 Nm
- Timing Cover Bolt12 lb-ft16 Nm
Timing Chain Kit3 specs
- Camshaft Sprocket Bolts75 lb-ft102 Nm
- Crankshaft balancer bolt110 lb-ft149 Nm
- Timing chain front cover bolts10 lb-ft14 Nm
Timing Chain Tensioner5 specs
- Camshaft Sprocket Bolts63 lb-ft86 Nm
- Crankshaft Pulley Bolt150 lb-ft203 Nm
- Guide Bolts21 lb-ft28 Nm
- Tensioner Bolt17 lb-ft23 Nm
- Timing Cover Bolt12 lb-ft16 Nm
Transmission Mount2 specs
- Crossmember Bolt82 lb-ft111 Nm
- Transmission Mount Bolts61 lb-ft83 Nm
Valve Cover Gasket - Single2 specs
- Ignition Coil Bolt9 lb-ft12 Nm
- Valve Cover BoltsDo not overtighten11 lb-ft15 Nm
Valve Cover Gaskets - Both2 specs
- Ignition Coil Bolt9 lb-ft12 Nm
- Valve Cover BoltsDo not overtighten12 lb-ft16 Nm

Cooling

Coolant Bypass Pipe4 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Coolant Flush5 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Coolant Reservoir4 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Coolant Temperature Sensor4 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Cooling Fan Assembly2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Cooling Fan Clutch2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Cooling Fan Motor2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Cooling Fan Relay1 spec
- Pump Bolts21 lb-ft28 Nm
Engine Oil Cooler2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Heater Control Valve2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Heater Core2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Heater Hoses2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Radiator8 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Shroud Bolts6 lb-ft8 Nm
- Hose Clamps3 lb-ft5 Nm
- Lower Hose Clamp3 lb-ft4 Nm
- Pump Bolts21 lb-ft28 Nm
- Radiator Mounting Bolt11 lb-ft15 Nm
- Transmission Cooler LinesUse new O-rings22 lb-ft30 Nm
- Upper Hose Clamp3 lb-ft4 Nm
Radiator Cap1 spec
- Pump Bolts21 lb-ft28 Nm
Radiator Hose - Lower2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Radiator Hose - Upper2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Radiator Hoses - Both2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
Thermostat5 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
- Thermostat Housing BoltClean mating surfaces11 lb-ft15 Nm
Thermostat Housing4 specs
- Coolant Hose Clamps3 lb-ft5 Nm
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm
- Thermostat Housing BoltClean surfaces12 lb-ft16 Nm
Water Pump5 specs
- Coolant Hose ClampsSpring clamps preferred3 lb-ft4 Nm
- Pump Bolts21 lb-ft28 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Timing Cover BoltIf accessed16 lb-ft22 Nm
- Water Pump BoltsTorque in sequence20 lb-ft27 Nm

Ignition

Spark Plug Wires3 specs
- Engine Cover Clips2 lb-ft3 Nm
- Ignition Coil Bolt9 lb-ft12 Nm
- Spark PlugGap before install17 lb-ft23 Nm
Spark Plugs3 specs
- Engine Cover Clips2 lb-ft3 Nm
- Ignition Coil Bolt9 lb-ft12 Nm
- Spark PlugGap before install, anti-seize optional16 lb-ft22 Nm

Fuel system

Fuel Filler Neck1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Filter3 specs
- Filter Bracket Bolt11 lb-ft15 Nm
- Fuel Line FittingsUse new O-rings22 lb-ft30 Nm
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Filter - In-Tank2 specs
- Filter Bracket Bolt12 lb-ft16 Nm
- Fuel Line FittingsNew O-rings23 lb-ft31 Nm
Fuel Injector - Single1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Injector Cleaning1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Injectors - All1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Line - High Pressure1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Line - Return1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Pressure Regulator1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Pump3 specs
- Access Cover Screws3 lb-ft4 Nm
- Fuel Pump Lock RingUse lock ring tool55 lb-ft75 Nm
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Pump Module2 specs
- Access Cover Screws3 lb-ft5 Nm
- Fuel Pump Lock RingLock ring tool58 lb-ft78 Nm
Fuel Rail1 spec
- Fuel Rail Bolts17 lb-ft23 Nm
Fuel Tank1 spec
- Fuel Rail Bolts17 lb-ft23 Nm

Electrical

Alternator4 specs
- Alternator Mounting Bolts38 lb-ft52 Nm
- Alternator Pivot Bolt38 lb-ft52 Nm
- Battery Cable NutDisconnect battery first11 lb-ft15 Nm
- Tensioner Bolt20 lb-ft27 Nm
Alternator Belt3 specs
- Alternator Mounting Bolts40 lb-ft55 Nm
- Alternator Pivot Bolt40 lb-ft55 Nm
- Battery Cable Nut12 lb-ft16 Nm
Battery4 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
- Ground Strap Bolts11 lb-ft15 Nm
Battery Cable - Negative3 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
Battery Cable - Positive3 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
Battery Cables - Both3 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
Battery Terminal3 specs
- Battery Hold-Down BoltDo not overtighten9 lb-ft12 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Ground Cable Bolt12 lb-ft16 Nm
Fuel Pump Relay2 specs
- Access Cover Screws3 lb-ft5 Nm
- Fuel Pump Lock RingLock ring tool58 lb-ft78 Nm
Starter3 specs
- Battery Cable Nut11 lb-ft15 Nm
- Solenoid Wire Nut6 lb-ft8 Nm
- Starter Mounting Bolt38 lb-ft52 Nm
Starter Solenoid2 specs
- Battery Cable Nut12 lb-ft16 Nm
- Starter Mounting Bolt40 lb-ft55 Nm

Suspension

Ball Joint - Lower6 specs
- Ball Joint Pinch BoltUse new bolt50 lb-ft68 Nm
- Control Arm Bolts109 lb-ft148 Nm
- Lower Ball Joint Castle NutUse new cotter pin82 lb-ft111 Nm
- Lower Ball Joint Nut75 lb-ft101 Nm
- Pinch BoltNew bolt52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Ball Joints - Upper and Lower4 specs
- Control Arm Bolts109 lb-ft148 Nm
- Lower Ball Joint Nut75 lb-ft101 Nm
- Pinch BoltNew bolt52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Spring - Front3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Spring - Rear3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Springs - Front Pair3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Coil Springs - Rear Pair3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Control Arm Bushing - Front Lower3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Lower Ball Joint NutNew cotter pin75 lb-ft101 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Control Arm Bushing - Rear3 specs
- Ball Joint NutNew cotter pin75 lb-ft101 Nm
- Control Arm Bolts109 lb-ft148 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Front Struts - Pair6 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Strut to Knuckle Bolts103 lb-ft140 Nm
- Strut Tower Nuts40 lb-ft55 Nm
- Sway Bar Link52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Knuckle/Spindle - Front4 specs
- Control Arm Bolts109 lb-ft148 Nm
- Lower Ball Joint Nut75 lb-ft101 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Knuckle/Spindle - Rear4 specs
- Ball Joint Nut75 lb-ft101 Nm
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Lateral Arm3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Lower Control Arm - Front4 specs
- Control Arm Bolts109 lb-ft148 Nm
- Lower Ball Joint Nut75 lb-ft101 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Radius Arm3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Radius Arm Bushing3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Rear Shocks - Pair2 specs
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Assembly - Rear4 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Tower Nuts40 lb-ft55 Nm
- Sway Bar Link52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Bearing4 specs
- Strut to Knuckle Bolts104 lb-ft140 Nm
- Strut Tower Nuts40 lb-ft55 Nm
- Sway Bar Link52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Mount - Front4 specs
- Strut to Knuckle Bolts103 lb-ft140 Nm
- Strut Tower Nuts40 lb-ft55 Nm
- Sway Bar Link52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Strut Mount - Rear4 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Tower Nuts40 lb-ft55 Nm
- Sway Bar Link52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Subframe3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Subframe Bushing3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Sway Bar - Front3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar - Rear3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar Bushing - Front3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar Bushing - Rear3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar Link - Front3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar Link - Rear3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Sway Bar Links - Front Pair3 specs
- Strut Bolts98 lb-ft133 Nm
- Sway Bar Bracket Bolts40 lb-ft55 Nm
- Sway Bar Link Nuts52 lb-ft70 Nm
Torsion Bar3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Torsion Bar Adjustment2 specs
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Trailing Arm3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Trailing Arm Bushing3 specs
- Control Arm Bolts109 lb-ft148 Nm
- Strut Bolts98 lb-ft133 Nm
- Wheel Lug Nuts100 lb-ft136 Nm

Steering

Power Steering Fluid Flush3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Hose - High Pressure3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Hose - Return3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Pump7 specs
- Pressure Line FittingUse new O-ring28 lb-ft38 Nm
- Pulley NutHold pulley while tightening50 lb-ft68 Nm
- Pump Mounting Bolts22 lb-ft30 Nm
- Return Line Clamp3 lb-ft4 Nm
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Pump Pulley4 specs
- Pressure Line FittingNew O-ring29 lb-ft39 Nm
- Pump Mounting Bolts23 lb-ft31 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Rack5 specs
- Pressure Line FittingNew O-ring29 lb-ft39 Nm
- Pump Mounting Bolts23 lb-ft31 Nm
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Power Steering Reservoir2 specs
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Rack and Pinion Boots2 specs
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Angle Sensor2 specs
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Column3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Coupler3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Damper2 specs
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Shaft - Intermediate3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Shaft - Upper2 specs
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Steering Wheel3 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod Assembly4 specs
- Tie Rod End NutNew cotter pin35 lb-ft47 Nm
- Tie Rod Lock NutAfter alignment58 lb-ft78 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod End - Inner5 specs
- Steering Rack Bolts86 lb-ft117 Nm
- Tie Rod End NutNew cotter pin35 lb-ft47 Nm
- Tie Rod Lock NutAfter alignment58 lb-ft78 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rod End - Outer4 specs
- Tie Rod End NutNew cotter pin35 lb-ft47 Nm
- Tie Rod Lock NutAfter alignment58 lb-ft78 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Tie Rods - Both Sides4 specs
- Tie Rod End NutNew cotter pin35 lb-ft47 Nm
- Tie Rod Lock NutAfter alignment58 lb-ft78 Nm
- Tie Rod Nut46 lb-ft62 Nm
- Wheel Lug Nuts100 lb-ft136 Nm

Drivetrain

Axle Seal - Front3 specs
- Axle Nut192 lb-ft260 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Axle - Front4 specs
- Axle Nut192 lb-ft260 Nm
- CV Bolts52 lb-ft70 Nm
- Lower Ball Joint Nut86 lb-ft117 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Axles - Front Pair4 specs
- Axle NutNew nut, stake192 lb-ft260 Nm
- CV Bolts52 lb-ft70 Nm
- Lower Ball Joint Nut86 lb-ft117 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Boot - Inner3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
CV Boot - Outer3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Differential Cover Gasket1 spec
- CV Bolts52 lb-ft70 Nm
Differential Pinion Seal1 spec
- CV Bolts52 lb-ft70 Nm
Differential Rebuild - Rear3 specs
- CV Bolts52 lb-ft70 Nm
- Drain PlugNew washer35 lb-ft47 Nm
- Fill Plug35 lb-ft47 Nm
Limited Slip Clutch Pack3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Ring and Pinion3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
U-Joint3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Bearing - Press-In Front4 specs
- ABS Sensor Bolt9 lb-ft12 Nm
- Axle NutNew nut, stake after192 lb-ft260 Nm
- Hub Bolts86 lb-ft117 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Bearing - Press-In Rear3 specs
- ABS Sensor Bolt9 lb-ft12 Nm
- Hub Bolts86 lb-ft117 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Bearing Hub - Front5 specs
- ABS Sensor Bolt9 lb-ft12 Nm
- Axle NutUse new nut, stake after192 lb-ft260 Nm
- CV Bolts52 lb-ft70 Nm
- Hub BoltsFrom backside of knuckle82 lb-ft111 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Bearing Hub - Rear4 specs
- ABS Sensor Bolt9 lb-ft12 Nm
- CV Bolts52 lb-ft70 Nm
- Hub Bolts72 lb-ft98 Nm
- Wheel Lug Nuts100 lb-ft136 Nm
Wheel Studs3 specs
- Axle Nut207 lb-ft281 Nm
- CV Bolts52 lb-ft70 Nm
- Wheel Lug Nuts100 lb-ft136 Nm

Transmission

Transmission Oil Cooler2 specs
- Hose Clamps3 lb-ft5 Nm
- Pump Bolts21 lb-ft28 Nm

Exhaust

Air Injection Check Valve1 spec
- Hanger Bolts17 lb-ft23 Nm
Catalytic Converter - California3 specs
- Hanger Bolts17 lb-ft23 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- O2 SensorAnti-seize40 lb-ft55 Nm
Catalytic Converter - Direct Fit3 specs
- Hanger Bolts17 lb-ft23 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- O2 SensorAnti-seize40 lb-ft55 Nm
Catalytic Converter - Universal3 specs
- Hanger Bolts17 lb-ft23 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- O2 SensorAnti-seize40 lb-ft55 Nm
Downpipe2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
EGR Tube1 spec
- Hanger Bolts17 lb-ft23 Nm
EGR Valve2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Exhaust Clamp1 spec
- Hanger Bolts17 lb-ft23 Nm
Exhaust Gasket - Front2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 SensorAnti-seize threads40 lb-ft55 Nm
Exhaust Gasket - Rear1 spec
- Hanger Bolts17 lb-ft23 Nm
Exhaust Hangers1 spec
- Hanger Bolts17 lb-ft23 Nm
Exhaust Manifold Studs2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 SensorAnti-seize threads40 lb-ft55 Nm
Exhaust Pipe - Rear Section1 spec
- Hanger Bolts17 lb-ft23 Nm
Exhaust Tip1 spec
- Hanger Bolts17 lb-ft23 Nm
Flex Pipe2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Front Pipe2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Intermediate Pipe2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Muffler2 specs
- Hanger Bolts16 lb-ft22 Nm
- O2 Sensor40 lb-ft55 Nm
O2 Sensor - Downstream2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
O2 Sensor - Upstream2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
O2 Sensors - All2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Resonator2 specs
- Hanger Bolts17 lb-ft23 Nm
- O2 Sensor40 lb-ft55 Nm
Secondary Air Injection Pump1 spec
- Hanger Bolts17 lb-ft23 Nm
Tail Pipe1 spec
- Hanger Bolts17 lb-ft23 Nm

Heating and A/C

AC Accumulator2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Clutch Coil1 spec
- Compressor Bolts29 lb-ft39 Nm
AC Compressor5 specs
- AC Compressor Bolts28 lb-ft38 Nm
- AC Line FittingsUse new O-rings, add oil16 lb-ft22 Nm
- Clutch Wire Connector3 lb-ft4 Nm
- Compressor Bolts29 lb-ft39 Nm
- Serpentine Belt Tensioner20 lb-ft27 Nm
AC Compressor Clutch1 spec
- Compressor Bolts29 lb-ft39 Nm
AC Compressor Oil Add2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Condenser4 specs
- AC Line FittingsUse new O-rings16 lb-ft22 Nm
- Compressor Bolts29 lb-ft39 Nm
- Condenser Mounting Bolts11 lb-ft15 Nm
- Fan Shroud Bolts6 lb-ft8 Nm
AC Evaporator5 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts29 lb-ft39 Nm
- Evaporator Case Screws6 lb-ft8 Nm
- Expansion Valve FittingUse new O-rings9 lb-ft12 Nm
AC Expansion Valve (TXV)2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC High Pressure Switch2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Hose - High Side2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Hose - Low Side2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Hose Assembly2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Low Pressure Switch2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Orifice Tube2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Pressure Sensor2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Receiver/Drier2 specs
- AC Line FittingsNew O-rings17 lb-ft23 Nm
- Compressor Bolts29 lb-ft39 Nm
AC Recharge1 spec
- Compressor Bolts29 lb-ft39 Nm
Blend Door Actuator1 spec
- Compressor Bolts29 lb-ft39 Nm
Cabin Air Filter1 spec
- Compressor Bolts29 lb-ft39 Nm
Climate Control Module1 spec
- Compressor Bolts29 lb-ft39 Nm
HVAC Control Panel1 spec
- Compressor Bolts29 lb-ft39 Nm
Mode Door Actuator1 spec
- Compressor Bolts29 lb-ft39 Nm
Recirculation Door Actuator1 spec
- Compressor Bolts29 lb-ft39 Nm

Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.

Need labor times, fluids or repair steps for this car? See it on the Open Labor Project