2009 Pontiac G5 torque specs

2.2L Ecotec I4 (LE5)

Change vehicle

Most looked up

Lug nuts105 lb-ft142.4 Nm
Oil drain plug18 lb-ft25 Nm
Spark plugs15 lb-ft20 Nm
Front caliper bracket bolts75 lb-ft102 Nm
Rear caliper bracket bolts75 lb-ft102 Nm
Front axle nut180 lb-ft244 Nm
Outer tie rod end nut40 lb-ft54 Nm

Maintenance

AC System Diagnosis1 spec
- AC Line FittingsNew O-rings15 lb-ft20 Nm
Air Filter2 specs
- MAF Sensor Screws3 lb-ft4 Nm
- Mass Air Flow Sensor Screws2 lb-ft3 Nm
Battery Test3 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Differential Service2 specs
- Drain PlugNew washer30 lb-ft41 Nm
- Fill Plug30 lb-ft41 Nm
Tire Rotation1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
TPMS Sensor2 specs
- TPMS Sensor NutUse TPMS torque wrench5 lb-ft7 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Alignment2 specs
- Cam BoltsAfter adjustment95 lb-ft129 Nm
- Tie Rod Lock NutAfter adjustment50 lb-ft68 Nm

Brakes

ABS Module3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
ABS Pump3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
ABS Tone Ring2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
ABS Wheel Speed Sensor - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
ABS Wheel Speed Sensor - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Bleed - All Four3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Booster3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Booster Check Valve2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Caliper - Front4 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers30 lb-ft41 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper - Rear4 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltUse new copper washers25 lb-ft34 Nm
- Caliper Mounting BoltsUse new bolts if specified55 lb-ft75 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper Bracket4 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltNew copper washers30 lb-ft41 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Caliper Rebuild - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Caliper Rebuild - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Caliper Slide Pins2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Drum - Rear2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Fluid Flush3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Hose - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Hose - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Light Switch2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Line - Single3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Lines - Complete Set3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Master Cylinder7 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Line FittingsUse line wrench15 lb-ft20 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Master Cylinder NutsTorque evenly20 lb-ft27 Nm
- Proportioning Valve Bolts18 lb-ft24 Nm
- Reservoir CapHand tight3 lb-ft4 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Pads - Front7 specs
- Bleeder ScrewCopper washer recommended10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Bracket Bolts - FrontTorque to spec, use thread locker75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsLubricate pins before install25 lb-ft34 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Pads - Rear8 specs
- Bleeder ScrewCopper washer recommended10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Bracket Bolts - RearTorque to spec, use thread locker55 lb-ft75 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Caliper Slide Pin BoltsLubricate pins before install25 lb-ft34 Nm
- Parking Brake AdjusterAdjust after pad install8 lb-ft11 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Pads and Rotors - Front5 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Pads and Rotors - Rear5 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Proportioning Valve3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Rotor - Front Single5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotor - Rear Single5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotors - Front Pair5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotors - Rear Pair5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Drum Brake Hardware Kit2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Drum Brake Shoes - Rear2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Electronic Parking Brake Motor2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Parking Brake Actuator2 specs
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Parking Brake Cable3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Parking Brake Shoes3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Cylinder3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm

Engine

Engine Mount - Front2 specs
- Engine Mount Through-Bolt65 lb-ft88 Nm
- Engine Mount-to-Frame Bolts45 lb-ft61 Nm
Engine Mount - Rear2 specs
- Engine Mount Through-Bolt65 lb-ft88 Nm
- Engine Mount-to-Frame Bolts45 lb-ft61 Nm
Engine Mounts - All2 specs
- Engine Mount Through-Bolt65 lb-ft88 Nm
- Engine Mount-to-Frame Bolts45 lb-ft61 Nm
Exhaust Manifold5 specs
- EGR Tube Fitting35 lb-ft47 Nm
- Exhaust Manifold NutsApply anti-seize25 lb-ft34 Nm
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Exhaust Manifold Gasket2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
Head Gasket - Single5 specs
- Camshaft Cap BoltsTorque sequence12 lb-ft16 Nm
- Cylinder Head BoltsMulti-step + angle65 lb-ft88 Nm
- Exhaust Manifold Nuts25 lb-ft34 Nm
- Intake Manifold Bolt18 lb-ft24 Nm
- Valve Cover Bolts10 lb-ft14 Nm
Head Gaskets - Both5 specs
- Camshaft Cap BoltsTorque sequence12 lb-ft16 Nm
- Cylinder Head BoltsMulti-step + angle65 lb-ft88 Nm
- Exhaust Manifold Nuts25 lb-ft34 Nm
- Intake Manifold Bolt18 lb-ft24 Nm
- Valve Cover Bolts10 lb-ft14 Nm
Intake Manifold3 specs
- Fuel Rail Bolts15 lb-ft20 Nm
- Intake Manifold BoltTorque sequence18 lb-ft24 Nm
- Throttle Body Bolts10 lb-ft14 Nm
Intake Manifold Gasket4 specs
- Fuel Rail Bolts15 lb-ft20 Nm
- Intake Manifold BoltTorque in sequence18 lb-ft24 Nm
- PCV Valve Fitting8 lb-ft11 Nm
- Throttle Body Bolts10 lb-ft14 Nm
Oil Change3 specs
- Oil Drain PlugUse new washer each time18 lb-ft25 Nm
- Oil Filler CapHand tight5 lb-ft7 Nm
- Oil FilterHand tight + 3/4 turn22 lb-ft30 Nm
Oil Pan Gasket4 specs
- Oil Drain PlugUse new washer25 lb-ft34 Nm
- Oil Level Sensor10 lb-ft14 Nm
- Oil Pan BoltTorque in sequence12 lb-ft16 Nm
- Oil Pickup Tube BoltsCheck O-ring15 lb-ft20 Nm
Throttle Body4 specs
- Air Intake Hose Clamp3 lb-ft4 Nm
- Air Intake Hose Clamps3 lb-ft4 Nm
- Coolant Hose ClampsIf coolant heated3 lb-ft4 Nm
- Throttle Body Bolts10 lb-ft14 Nm
Timing Chain5 specs
- Camshaft Sprocket Bolts52 lb-ft70 Nm
- Crankshaft pulley/balancer bolt74 lb-ft100 Nm
- Timing chain cover bolts (M6)7.4 lb-ft10 Nm
- Timing chain guide bolts7.4 lb-ft10 Nm
- Timing chain tensioner bolts7.4 lb-ft10 Nm
Timing Chain Guide3 specs
- Crankshaft Pulley Bolt74 lb-ft100 Nm
- Timing chain guide bolts7.4 lb-ft10 Nm
- Timing chain tensioner bolts7.4 lb-ft10 Nm
Timing Chain Kit5 specs
- Camshaft Sprocket Bolts52 lb-ft70 Nm
- Crankshaft pulley/balancer bolt74 lb-ft100 Nm
- Timing chain cover bolts (M6)7.4 lb-ft10 Nm
- Timing chain guide bolts7.4 lb-ft10 Nm
- Timing chain tensioner bolts7.4 lb-ft10 Nm
Timing Chain Tensioner3 specs
- Crankshaft Pulley Bolt74 lb-ft100 Nm
- Timing chain cover bolts (M6)7.4 lb-ft10 Nm
- Timing chain tensioner bolts7.4 lb-ft10 Nm
Transmission Mount2 specs
- Crossmember Bolt75 lb-ft102 Nm
- Transmission Mount Bolts55 lb-ft75 Nm
Valve Cover Gasket - Single2 specs
- Ignition Coil Bolt8 lb-ft11 Nm
- Valve Cover BoltsDo not overtighten10 lb-ft14 Nm
Valve Cover Gaskets - Both2 specs
- Ignition Coil Bolt8 lb-ft11 Nm
- Valve Cover BoltsDo not overtighten10 lb-ft14 Nm

Cooling

Coolant Bypass Pipe4 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Coolant Flush5 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Coolant Reservoir4 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Coolant Temperature Sensor4 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Cooling Fan Assembly2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Cooling Fan Clutch2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Cooling Fan Motor2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Cooling Fan Relay1 spec
- Pump Bolts18 lb-ft24 Nm
Heater Control Valve2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Heater Core2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Heater Hoses2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Radiator8 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Shroud Bolts5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Lower Hose Clamp3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
- Radiator Mounting Bolt10 lb-ft14 Nm
- Transmission Cooler LinesUse new O-rings20 lb-ft27 Nm
- Upper Hose Clamp3 lb-ft4 Nm
Radiator Cap1 spec
- Pump Bolts18 lb-ft24 Nm
Radiator Hose - Lower2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Radiator Hose - Upper2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Radiator Hoses - Both2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
Thermostat5 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing BoltClean mating surfaces10 lb-ft14 Nm
Thermostat Housing4 specs
- Coolant Hose Clamps3 lb-ft4 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing BoltClean surfaces10 lb-ft14 Nm
Water Pump5 specs
- Coolant Hose ClampsSpring clamps preferred3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
- Timing Cover BoltIf accessed15 lb-ft20 Nm
- Water Pump BoltsTorque in sequence18 lb-ft24 Nm

Ignition

Spark Plugs3 specs
- Engine Cover Clips2 lb-ft3 Nm
- Ignition Coil Bolt8 lb-ft11 Nm
- Spark PlugGap before install, anti-seize optional15 lb-ft20 Nm

Fuel system

Fuel Filler Neck1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Filter3 specs
- Filter Bracket Bolt10 lb-ft14 Nm
- Fuel Line FittingsUse new O-rings20 lb-ft27 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Filter - In-Tank2 specs
- Filter Bracket Bolt10 lb-ft14 Nm
- Fuel Line FittingsNew O-rings20 lb-ft27 Nm
Fuel Injector - Single1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Injector Cleaning1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Injectors - All1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Line - High Pressure1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Line - Return1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Pressure Regulator1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Pump3 specs
- Access Cover Screws3 lb-ft4 Nm
- Fuel Pump Lock RingUse lock ring tool50 lb-ft68 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Pump Module2 specs
- Access Cover Screws3 lb-ft4 Nm
- Fuel Pump Lock RingLock ring tool50 lb-ft68 Nm
Fuel Rail1 spec
- Fuel Rail Bolts15 lb-ft20 Nm
Fuel Tank1 spec
- Fuel Rail Bolts15 lb-ft20 Nm

Electrical

Alternator4 specs
- Alternator Mounting Bolts35 lb-ft47 Nm
- Alternator Pivot Bolt35 lb-ft47 Nm
- Battery Cable NutDisconnect battery first10 lb-ft14 Nm
- Tensioner Bolt18 lb-ft24 Nm
Alternator Belt3 specs
- Alternator Mounting Bolts35 lb-ft47 Nm
- Alternator Pivot Bolt35 lb-ft47 Nm
- Battery Cable Nut10 lb-ft14 Nm
Battery4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap Bolts10 lb-ft14 Nm
Battery Cable - Negative3 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Battery Cable - Positive3 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Battery Cables - Both3 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Battery Terminal3 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Fuel Pump Relay2 specs
- Access Cover Screws3 lb-ft4 Nm
- Fuel Pump Lock RingLock ring tool50 lb-ft68 Nm
Starter3 specs
- Battery Cable Nut10 lb-ft14 Nm
- Solenoid Wire Nut5 lb-ft7 Nm
- Starter Mounting Bolt35 lb-ft47 Nm
Starter Solenoid2 specs
- Battery Cable Nut10 lb-ft14 Nm
- Starter Mounting Bolt35 lb-ft47 Nm

Suspension

Ball Joint - Lower6 specs
- Ball Joint Pinch BoltUse new bolt45 lb-ft61 Nm
- Control Arm Bolts95 lb-ft129 Nm
- Lower Ball Joint Castle NutUse new cotter pin75 lb-ft102 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Ball Joint - Upper1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Ball Joints - Upper and Lower4 specs
- Control Arm Bolts95 lb-ft129 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Coil Spring - Front3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Coil Spring - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Coil Springs - Front Pair3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Coil Springs - Rear Pair1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Control Arm Bushing - Front Lower3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Lower Ball Joint NutNew cotter pin65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Control Arm Bushing - Front Upper1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Control Arm Bushing - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Front Struts - Pair6 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Knuckle/Spindle - Front4 specs
- Control Arm Bolts95 lb-ft129 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Knuckle/Spindle - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Lateral Arm3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Lower Control Arm - Front4 specs
- Control Arm Bolts95 lb-ft129 Nm
- Lower Ball Joint Nut65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Lower Control Arm - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Radius Arm3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Radius Arm Bushing3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Rear Shocks - Pair1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Strut Assembly - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Strut Bearing4 specs
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Strut Mount - Front4 specs
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Strut Mount - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Subframe3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Subframe Bushing3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Sway Bar - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar - Rear2 specs
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar Bushing - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar Bushing - Rear2 specs
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar Link - Front3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar Link - Rear2 specs
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Sway Bar Links - Front Pair3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
Torsion Bar3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Torsion Bar Adjustment2 specs
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Trailing Arm3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Trailing Arm Bushing3 specs
- Control Arm Bolts95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Upper Control Arm - Front1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Upper Control Arm - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm

Steering

Electric Power Steering Module3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Electric Power Steering Motor3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Hose - High Pressure3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Hose - Return3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Rack5 specs
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Reservoir2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Rack and Pinion Boots2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Angle Sensor2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Column3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Coupler3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Damper2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Shaft - Intermediate3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Shaft - Upper2 specs
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Wheel3 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod Assembly4 specs
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod End - Inner5 specs
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod End - Outer4 specs
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rods - Both Sides4 specs
- Tie Rod End NutNew cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm

Drivetrain

Axle Seal - Front3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axle - Front4 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axle - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axles - Front Pair4 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Boot - Inner3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Boot - Outer3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Cover Gasket2 specs
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Fluid Change - Rear1 spec
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Pinion Seal2 specs
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Rebuild - Rear4 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Drain PlugNew washer30 lb-ft41 Nm
- Fill Plug30 lb-ft41 Nm
Limited Slip Clutch Pack3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Ring and Pinion3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
U-Joint3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing - Press-In Front4 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutNew nut, stake after180 lb-ft244 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing - Press-In Rear4 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutNew nut, stake after180 lb-ft244 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing Hub - Front5 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Hub BoltsFrom backside of knuckle75 lb-ft102 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing Hub - Rear5 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new nut160 lb-ft217 Nm
- CV Bolts45 lb-ft61 Nm
- Hub Bolts65 lb-ft88 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Studs3 specs
- Axle Nut180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm

Transmission

Clutch Hydraulic Line2 specs
- Bell Housing Bolts35 lb-ft47 Nm
- Pressure Plate BoltStar pattern20 lb-ft27 Nm
Transmission Oil Cooler2 specs
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm

Exhaust

Catalytic Converter - Direct Fit3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- O2 SensorAnti-seize35 lb-ft47 Nm
Catalytic Converter - Universal3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- O2 SensorAnti-seize35 lb-ft47 Nm
Downpipe2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
EGR Tube1 spec
- Hanger Bolts15 lb-ft20 Nm
EGR Valve2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
Exhaust Clamp1 spec
- Hanger Bolts15 lb-ft20 Nm
Exhaust Gasket - Front2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
Exhaust Gasket - Rear1 spec
- Hanger Bolts15 lb-ft20 Nm
Exhaust Hangers1 spec
- Hanger Bolts15 lb-ft20 Nm
Exhaust Manifold Studs2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
Exhaust Pipe - Rear Section1 spec
- Hanger Bolts15 lb-ft20 Nm
Exhaust Tip1 spec
- Hanger Bolts15 lb-ft20 Nm
Flex Pipe2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
Front Pipe2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
Intermediate Pipe2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
Muffler2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
O2 Sensor - Downstream2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
O2 Sensor - Upstream2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
O2 Sensors - All2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 SensorAnti-seize threads35 lb-ft47 Nm
Resonator2 specs
- Hanger Bolts15 lb-ft20 Nm
- O2 Sensor35 lb-ft47 Nm
Tail Pipe1 spec
- Hanger Bolts15 lb-ft20 Nm

Heating and A/C

AC Accumulator2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Clutch Coil1 spec
- Compressor Bolts25 lb-ft34 Nm
AC Compressor5 specs
- AC Compressor Bolts25 lb-ft34 Nm
- AC Line FittingsUse new O-rings, add oil15 lb-ft20 Nm
- Clutch Wire Connector3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Serpentine Belt Tensioner18 lb-ft24 Nm
AC Compressor Clutch1 spec
- Compressor Bolts25 lb-ft34 Nm
AC Compressor Oil Add2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Condenser4 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
- Condenser Mounting Bolts10 lb-ft14 Nm
- Fan Shroud Bolts5 lb-ft7 Nm
AC Evaporator5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Evaporator Case Screws5 lb-ft7 Nm
- Expansion Valve FittingUse new O-rings8 lb-ft11 Nm
AC Expansion Valve (TXV)2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC High Pressure Switch2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Hose - High Side2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Hose - Low Side2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Hose Assembly2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Low Pressure Switch2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Orifice Tube2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Pressure Sensor2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Receiver/Drier2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Compressor Bolts25 lb-ft34 Nm
AC Recharge1 spec
- Compressor Bolts25 lb-ft34 Nm
Blend Door Actuator1 spec
- Compressor Bolts25 lb-ft34 Nm
Cabin Air Filter1 spec
- Compressor Bolts25 lb-ft34 Nm
Climate Control Module1 spec
- Compressor Bolts25 lb-ft34 Nm
HVAC Control Panel1 spec
- Compressor Bolts25 lb-ft34 Nm
Mode Door Actuator1 spec
- Compressor Bolts25 lb-ft34 Nm
Recirculation Door Actuator1 spec
- Compressor Bolts25 lb-ft34 Nm

Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.

Need labor times, fluids or repair steps for this car? See it on the Open Labor Project