RQUE SPECS2017 Nissan Titan XD torque specs
5.0L V8 Cummins Diesel
Change vehicle
Most looked up
- Lug nuts135 lb-ft183 Nm
- Oil drain plug37 lb-ft50 Nm
- Spark plugs15 lb-ft20 Nm
- Front caliper bracket bolts152 lb-ft206 Nm
- Rear caliper bracket bolts74 lb-ft100 Nm
- Front axle nut199 lb-ft270 Nm
- Outer tie rod end nut65 lb-ft88 Nm
Maintenance
AC System Diagnosis2 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Connector Bolts6 lb-ft8 Nm
Air Filter3 specs
- Intake Tube Clamp4 lb-ft5 Nm
- MAF Sensor Screws4 lb-ft5 Nm
- Mass Air Flow Sensor Screws2 lb-ft3 Nm
Battery Test4 specs
- Battery Hold-Down BoltDo not overtighten10 lb-ft14 Nm
- Battery Terminal BoltsClean terminals6 lb-ft8 Nm
- Connector Bolts6 lb-ft8 Nm
- Ground Cable Bolt13 lb-ft17 Nm
Charging System Test1 spec
- Connector Bolts6 lb-ft8 Nm
Check Engine Light Diagnosis1 spec
- Connector Bolts6 lb-ft8 Nm
Compression Test1 spec
- Connector Bolts6 lb-ft8 Nm
Cooling System Pressure Test1 spec
- Connector Bolts6 lb-ft8 Nm
Diagnostic Scan1 spec
- Connector Bolts6 lb-ft8 Nm
Differential Service3 specs
- Connector Bolts6 lb-ft8 Nm
- Drain PlugNew washer38 lb-ft51 Nm
- Fill Plug38 lb-ft51 Nm
Drivability Diagnosis1 spec
- Connector Bolts6 lb-ft8 Nm
Electrical Diagnosis1 spec
- Connector Bolts6 lb-ft8 Nm
Fluid Leak Diagnosis1 spec
- Connector Bolts6 lb-ft8 Nm
Leak-Down Test1 spec
- Connector Bolts6 lb-ft8 Nm
Noise Diagnosis1 spec
- Connector Bolts6 lb-ft8 Nm
Power Steering Service3 specs
- Connector Bolts6 lb-ft8 Nm
- Pressure Line FittingNew O-ring31 lb-ft42 Nm
- Pump Mounting Bolts25 lb-ft34 Nm
Tire Balance1 spec
- Connector Bolts6 lb-ft8 Nm
Tire Mount and Balance1 spec
- Connector Bolts6 lb-ft8 Nm
Tire Rotation2 specs
- Lug Nuts - Alloy WheelsTorque in star pattern, recheck after 50 miles133 lb-ft180 Nm
- Lug Nuts - Steel WheelsTorque in star pattern133 lb-ft180 Nm
TPMS Relearn1 spec
- Connector Bolts6 lb-ft8 Nm
TPMS Sensor3 specs
- Connector Bolts6 lb-ft8 Nm
- TPMS Sensor NutUse TPMS torque wrench6 lb-ft8 Nm
- Wheel Lug Nuts133 lb-ft180 Nm
Transmission Service1 spec
- Connector Bolts6 lb-ft8 Nm
Tune-Up - Major1 spec
- Connector Bolts6 lb-ft8 Nm
Tune-Up - Minor1 spec
- Connector Bolts6 lb-ft8 Nm
Wheel Alignment4 specs
- Cam BoltsAfter adjustment114 lb-ft155 Nm
- Connector Bolts6 lb-ft8 Nm
- Subframe BoltsIf adjusted106 lb-ft144 Nm
- Tie Rod Lock NutAfter adjustment60 lb-ft81 Nm
Brakes
ABS Module3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
ABS Pump3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
ABS Tone Ring2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
ABS Wheel Speed Sensor - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
ABS Wheel Speed Sensor - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Bleed - All Four3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Booster3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Booster Check Valve2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Caliper - Front3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended152 lb-ft206 Nm
Brake Caliper - Rear3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
Brake Caliper Bracket4 specs
- Bleeder Screw12 lb-ft16 Nm
- Brake Hose Banjo BoltNew copper washers38 lb-ft51 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Caliper Rebuild - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Caliper Rebuild - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Caliper Slide Pins2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Drum - Rear2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Fluid Flush5 specs
- Bleeder ScrewFront and rear12 lb-ft16 Nm
- Caliper Mounting Bolts81 lb-ft110 Nm
- Connector Bolts6 lb-ft8 Nm
- Master Cylinder CapHand tight4 lb-ft5 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Brake Hose - Front3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Hose - Rear3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Light Switch2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Line - Single3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Lines - Complete Set3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Master Cylinder2 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Nuts18 lb-ft25 Nm
Brake Master Cylinder Rebuild3 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Mounting Nuts18 lb-ft25 Nm
- Reservoir Mounting Bolts6 lb-ft8 Nm
Brake Pads - Front3 specs
- Caliper Bracket BoltsThreadlocker recommended152 lb-ft206 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern133 lb-ft180 Nm
Brake Pads - Rear3 specs
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
- Caliper Slide Pin BoltsApply silicone brake grease22 lb-ft30 Nm
- Wheel Lug NutsTorque in star pattern133 lb-ft180 Nm
Brake Pads and Rotors - Front5 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Bracket BoltsUse thread locker152 lb-ft206 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Caliper Slide BoltsLubricate pins32 lb-ft44 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Pads and Rotors - Rear5 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Bracket BoltsUse thread locker94 lb-ft127 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Caliper Slide BoltsLubricate pins31 lb-ft42 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Proportioning Valve3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Rotor - Front Single5 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts152 lb-ft206 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Hub NutIf removed199 lb-ft270 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Rotor - Rear Single4 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts94 lb-ft127 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Rotors - Front Pair5 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts152 lb-ft206 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Hub NutIf removed199 lb-ft270 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Brake Rotors - Rear Pair4 specs
- Brake Rotor Set Screw6 lb-ft8 Nm
- Caliper Bracket Bolts94 lb-ft127 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Drum Brake Hardware Kit2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Drum Brake Shoes - Rear2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Electronic Parking Brake Motor2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Front Brake Pad Replacement3 specs
- Caliper Bracket BoltsThreadlocker recommended152 lb-ft206 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern133 lb-ft180 Nm
Parking Brake Actuator2 specs
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Parking Brake Cable3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Parking Brake Shoes3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Rear Brake Shoe Replacement3 specs
- Backing Plate Bolts44 lb-ft60 Nm
- Wheel Cylinder Bolts9 lb-ft12 Nm
- Wheel Lug NutsTorque in star pattern133 lb-ft180 Nm
Wheel Cylinder3 specs
- Bleeder Screw12 lb-ft16 Nm
- Caliper Mounting BoltsUse thread locker81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Engine
Boost Pressure Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Camshaft Position Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Camshaft R&R3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Connecting Rod Bearings3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Crankshaft Position Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Crankshaft R&R3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Cylinder Head R&R3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Cylinder Head Resurface3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Engine Mount - Front3 specs
- Engine Mount Through-Bolt63 lb-ft85 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
Engine Mount - Rear5 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Engine Mount Through-Bolt81 lb-ft110 Nm
- Engine Mount-to-Frame Bolts56 lb-ft76 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Engine Mounts - All5 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Engine Mount Through-Bolt81 lb-ft110 Nm
- Engine Mount-to-Frame Bolts56 lb-ft76 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Engine R&R3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Engine Rebuild3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Exhaust Manifold8 specs
- EGR Tube Fitting42 lb-ft57 Nm
- Electrical Connector Bolts6 lb-ft8 Nm
- Exhaust Manifold NutsApply anti-seize30 lb-ft41 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Hanger Bolts19 lb-ft25 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- O2 SensorApply anti-seize to threads42 lb-ft57 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Exhaust Manifold Gasket3 specs
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Exhaust Manifold StudsIf replacing studs11 lb-ft15 Nm
- Heat Shield Bolts7 lb-ft10 Nm
Fan Belt Replacement3 specs
- Idler Pulley Bolt30 lb-ft40 Nm
- Tensioner Bolt18 lb-ft25 Nm
- Tensioner Pulley Bolt33 lb-ft45 Nm
Flexplate3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Freeze Plug - Single3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Freeze Plugs - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Front Main Seal3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Full Engine Tune-Up5 specs
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Spark Plugs - Cast Iron HeadApply anti-seize to threads22 lb-ft30 Nm
- Throttle Body Bolts7 lb-ft10 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Glow Plugs - Replace All1 spec
- Glow PlugsHand-start, then torque. Over-torque snaps the tip; a seized plug needs extraction11.1 lb-ft15 Nm
Harmonic Balancer3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Head Gasket - Single6 specs
- Exhaust Manifold NutsApply anti-seize18 lb-ft25 Nm
- Intake Manifold BoltTighten in sequence18 lb-ft25 Nm
- Cylinder Head Bolts - Step 1Always use new TTY bolts30 lb-ft40 Nm
- Cylinder Head Bolts - Step 2Tighten in sequence59 lb-ft80 Nm
- Cylinder Head Bolts - Step 3Plus 90 degreesTurn 90°
- Cylinder Head Bolts - Step 4Plus 90 degreesTurn 90°
Head Gaskets - Both8 specs
- Camshaft Cap BoltsTorque sequence15 lb-ft20 Nm
- Cylinder Head BoltsMulti-step + angle81 lb-ft110 Nm
- Electrical Connector Bolts6 lb-ft8 Nm
- Exhaust Manifold Nuts31 lb-ft42 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Intake Manifold Bolt23 lb-ft31 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
- Valve Cover Bolts13 lb-ft17 Nm
Idle Air Control Valve3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Idler Pulley3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Intake Manifold6 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Fuel Rail Bolts19 lb-ft25 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Intake Manifold BoltTorque sequence23 lb-ft31 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
- Throttle Body Bolts13 lb-ft17 Nm
Intake Manifold Gasket3 specs
- Fuel Rail Bolts9 lb-ft12 Nm
- Intake Manifold BoltTighten in sequence from center out18 lb-ft25 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Intercooler3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Knock Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Lifter - Single3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Lifters/Tappets - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Long Block Replacement3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Main Bearings3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Manifold Absolute Pressure Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Mass Air Flow Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Oil Change2 specs
- Oil Drain PlugUse new crush washer37 lb-ft50 Nm
- Oil Filter (Spin-On)Hand tight plus 3/4 turn18 lb-ft25 Nm
Oil Level Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Oil Pan Gasket2 specs
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence from center outward9 lb-ft12 Nm
Oil Pan Replacement3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Oil Pressure Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Oil Pump3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
PCV Valve3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Piston - Single3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Piston Rings - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Pistons - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Rear Main Seal3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Rocker Arms - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Serpentine Belt2 specs
- Belt Tensioner Bolt41 lb-ft55 Nm
- Idler Pulley Bolt33 lb-ft45 Nm
Serpentine Belt Tensioner3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Short Block Replacement3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Throttle Body2 specs
- Air Intake Hose Clamps2 lb-ft3 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Throttle Position Sensor3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Transmission Mount4 specs
- Crossmember Bolt70 lb-ft95 Nm
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
- Transmission Mount Bolts48 lb-ft65 Nm
Turbo Wastegate Actuator3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Turbocharger3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Valve Adjustment3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Valve Cover Gasket - Single2 specs
- Spark Plug Tube SealsIf equipped with separate seals9 lb-ft12 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Cover Gaskets - Both5 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Ignition Coil Bolt10 lb-ft14 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
- Valve Cover BoltsDo not overtighten13 lb-ft17 Nm
Valve Job - Complete3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Valve Seals3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Valve Spring - Single3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Valve Springs - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Variable Valve Timing Actuator3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
VVT Solenoid - Single3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
VVT Solenoids - All3 specs
- Electrical Connector Bolts6 lb-ft8 Nm
- Gasket Surface BoltsClean mating surfaces19 lb-ft26 Nm
- Sensor Mounting Bolts10 lb-ft14 Nm
Cooling
Coolant Bypass Pipe6 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Coolant Flush8 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Block Drain PlugIf equipped, use new washer18 lb-ft25 Nm
- Connector Bolts6 lb-ft8 Nm
- Coolant Hose Clamps4 lb-ft5 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Hose Clamps4 lb-ft5 Nm
- Pump Bolts23 lb-ft31 Nm
- Radiator CapHand tight1 lb-ft1 Nm
Coolant Reservoir6 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Coolant Temperature Sensor6 specs
- Bleed ScrewOpen during fill6 lb-ft8 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Cooling Fan Assembly5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Cooling Fan Clutch5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Cooling Fan Motor5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Cooling Fan Relay4 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Engine Oil Cooler5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Heater Control Valve5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Heater Core5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Heater Hoses5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Radiator4 specs
- Drain PetcockPlastic - hand tight4 lb-ft5 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped18 lb-ft25 Nm
- Upper/Lower Hose Clamps2 lb-ft3 Nm
Radiator Cap4 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Radiator Hose - Lower5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Radiator Hose - Upper5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Radiator Hoses - Both5 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Radiator Removal and Service4 specs
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
- Fan Shroud Bolts7 lb-ft10 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped, use new washers18 lb-ft25 Nm
Thermostat2 specs
- Coolant Temperature SensorUse thread sealant15 lb-ft20 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Thermostat Housing6 specs
- Coolant Hose Clamps4 lb-ft5 Nm
- Drain PetcockHand tight6 lb-ft8 Nm
- Fan Bolts10 lb-ft14 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Water Pump3 specs
- Hose ClampsSpring clamps preferred2 lb-ft3 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Ignition
Ignition Control Module1 spec
- Connector Bolts6 lb-ft8 Nm
Ignition Lock Cylinder1 spec
- Connector Bolts6 lb-ft8 Nm
Ignition Switch1 spec
- Connector Bolts6 lb-ft8 Nm
Spark Plugs3 specs
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Spark Plugs - Cast Iron HeadApply anti-seize to threads22 lb-ft30 Nm
Fuel system
Charcoal Canister3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
EVAP Purge Valve3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
EVAP Vent Valve3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Cap3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Filler Neck4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Filter4 specs
- Connector Bolts6 lb-ft8 Nm
- Filter Bracket Bolt13 lb-ft17 Nm
- Fuel Filter Bracket Bolt7 lb-ft10 Nm
- Fuel Line FittingsIf threaded type18 lb-ft25 Nm
Fuel Filter - In-Tank5 specs
- Filter Bracket10 lb-ft14 Nm
- Filter Bracket Bolt13 lb-ft17 Nm
- Fuel Line FittingsNew O-rings25 lb-ft34 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Injector - Single4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Injector Cleaning4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Injectors - All4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Level Sensor3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Line - High Pressure4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Line - Return4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Pressure Regulator4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Pump2 specs
- Fuel Pump Module Lock RingUse special tool59 lb-ft80 Nm
- Tank Strap Bolts26 lb-ft35 Nm
Fuel Pump Module5 specs
- Access Cover Screws4 lb-ft5 Nm
- Filter Bracket10 lb-ft14 Nm
- Fuel Pump Lock RingLock ring tool63 lb-ft85 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Rail4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Tank4 specs
- Filter Bracket10 lb-ft14 Nm
- Fuel Rail Bolts19 lb-ft26 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Fuel Tank Strap3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
High Pressure Fuel Pump3 specs
- Filter Bracket10 lb-ft14 Nm
- Pressure Regulator Screws6 lb-ft8 Nm
- Pump Mounting12 lb-ft16 Nm
Electrical
Airbag - Driver3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Airbag - Passenger3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Airbag - Side3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Airbag Module/Computer2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Alternator4 specs
- Alternator Mounting Bolts37 lb-ft50 Nm
- Alternator Pivot Bolt18 lb-ft25 Nm
- Battery Terminal BoltsDo not overtighten6 lb-ft8 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Alternator Belt4 specs
- Alternator Mounting Bolts44 lb-ft59 Nm
- Alternator Pivot Bolt44 lb-ft59 Nm
- Battery Cable Nut13 lb-ft17 Nm
- Connector Screws4 lb-ft5 Nm
Amplifier3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Antenna2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Backup Camera2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Battery3 specs
- Battery Hold-Down Bolt6 lb-ft8 Nm
- Battery Terminal BoltsDo not overtighten - can crack terminal4 lb-ft6 Nm
- Battery Tray Bolts9 lb-ft12 Nm
Battery Cable - Negative5 specs
- Battery Hold-Down BoltDo not overtighten10 lb-ft14 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt13 lb-ft17 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Battery Cable - Positive4 specs
- Battery Hold-Down BoltDo not overtighten10 lb-ft14 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt13 lb-ft17 Nm
Battery Cables - Both5 specs
- Battery Hold-Down BoltDo not overtighten10 lb-ft14 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt13 lb-ft17 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Battery Terminal5 specs
- Battery Hold-Down BoltDo not overtighten10 lb-ft14 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt13 lb-ft17 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Blower Motor2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Blower Motor Resistor Screws1.5 lb-ft2 Nm
Blower Motor Control Module2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Blower Motor Resistor3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Clock Spring3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Combination Switch2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Dimmer Switch2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Door Lock Actuator - Front2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Door Lock Actuator - Rear2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Fog Light Assembly2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Fog Light Bulb1 spec
- Connector Screws4 lb-ft5 Nm
Fuel Pump Relay5 specs
- Access Cover Screws4 lb-ft5 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Fuel Pump Lock RingLock ring tool63 lb-ft85 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Fuse Box - Engine Bay3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Fuse Box - Interior3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Headlight Assembly3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Headlight Bulb - Single3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Headlight Bulbs - Pair1 spec
- Connector Screws4 lb-ft5 Nm
Headlight Switch2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Heated Seat Module2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
HID Ballast2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Horn3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Horn Relay2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Instrument Cluster2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
LED Headlight Module2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Main Relay2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Antenna Motor2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Mirror Motor2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Seat Motor2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Window Motor - Front2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Window Motor - Rear2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Window Regulator - Front2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Power Window Regulator - Rear2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Radio/Head Unit2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Relay - Generic2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Seat Heater Element2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Side Mirror Assembly2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Speaker - Dash2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Speaker - Door2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Speedometer2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Starter3 specs
- Heat Shield BoltsIf equipped7 lb-ft10 Nm
- Starter Mounting BoltLong bolt may need extension37 lb-ft50 Nm
- Starter Solenoid NutFor B+ cable9 lb-ft12 Nm
Starter Solenoid4 specs
- Battery Cable Nut13 lb-ft17 Nm
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Starter Mounting Bolt44 lb-ft59 Nm
Subwoofer2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Sunroof Motor2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Sunroof Switch2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Tail Light Assembly3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Tail Light Bulb1 spec
- Connector Screws4 lb-ft5 Nm
Third Brake Light1 spec
- Connector Screws4 lb-ft5 Nm
Trunk/Liftgate Actuator2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Turn Signal Bulb - Front1 spec
- Connector Screws4 lb-ft5 Nm
Turn Signal Bulb - Rear1 spec
- Connector Screws4 lb-ft5 Nm
Turn Signal Switch3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Voltage Regulator2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Washer Pump2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Washer Reservoir2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Window Motor and Regulator - Front2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Window Motor and Regulator - Rear2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Wiper Linkage3 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces12 lb-ft16 Nm
Wiper Motor - Front2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Wiper Motor - Rear2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Wiper Switch2 specs
- Battery Terminal Bolts6 lb-ft8 Nm
- Connector Screws4 lb-ft5 Nm
Suspension
Ball Joint - Lower8 specs
- Ball Joint Pinch BoltUse new bolt54 lb-ft73 Nm
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Lower Ball Joint Castle NutUse new cotter pin90 lb-ft122 Nm
- Lower Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Pinch BoltNew bolt56 lb-ft76 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug Nuts133 lb-ft180 Nm
Ball Joint - Upper6 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Pinch BoltNew bolt56 lb-ft76 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Upper Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Ball Joints - Upper and Lower7 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Lower Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Pinch BoltNew bolt56 lb-ft76 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Upper Ball Joint NutUse new cotter pin81.1 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Coil Spring - Front4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Coil Springs - Front Pair4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Control Arm Bushing - Front Lower5 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Lower Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Control Arm Bushing - Front Upper5 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Upper Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Front Struts - Pair5 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Strut Tower Nuts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Front Suspension Rebuild5 specs
- Ball Joint Pinch BoltUse new bolt if locknut style37 lb-ft50 Nm
- Lower Control Arm BoltsTorque at ride height81 lb-ft110 Nm
- Strut Top Mount Nuts18 lb-ft25 Nm
- Sway Bar End Link Nuts44 lb-ft60 Nm
- Upper Control Arm BoltsTorque at ride height66 lb-ft90 Nm
Knuckle/Spindle - Front6 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Lower Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Upper Ball Joint NutUse new cotter pin81.1 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Lateral Arm4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Leaf Spring3 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Leaf Spring Bushing3 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Leaf Spring Shackle3 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Leaf Spring U-Bolt Kit3 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Lower Control Arm - Front5 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Lower Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Radius Arm4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Radius Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Rear Shocks - Pair2 specs
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Rear Suspension Service3 specs
- Shock Lower Bolt52 lb-ft70 Nm
- Sway Bar End Link Nuts37 lb-ft50 Nm
- Trailing Arm BoltsTorque at ride height88 lb-ft120 Nm
Shock Absorber Replacement2 specs
- Lower Mount Bolt66 lb-ft90 Nm
- Upper Mount NutUse new self-locking nut41 lb-ft55 Nm
Strut Assembly - Front3 specs
- Strut Mount Center NutHold strut shaft with Allen key41 lb-ft55 Nm
- Strut Tower NutsDo not loosen center nut unless compressed37 lb-ft50 Nm
- Sway Bar End Link Nuts41 lb-ft55 Nm
Strut Bearing5 specs
- Strut Bolts106 lb-ft144 Nm
- Strut to Knuckle Bolts113 lb-ft153 Nm
- Strut Tower Nuts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Strut Mount - Front4 specs
- Strut Bolts106 lb-ft144 Nm
- Strut Tower Nuts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Subframe4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Subframe Bushing4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar - Front5 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar - Rear4 specs
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar Bushing - Front5 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar Bushing - Rear4 specs
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar Link - Front5 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar Link - Rear4 specs
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Sway Bar Links - Front Pair5 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Bracket Bolts44 lb-ft59 Nm
- Sway Bar Link56 lb-ft76 Nm
- Sway Bar Link Nuts56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Torsion Bar4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Torsion Bar Adjustment3 specs
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Trailing Arm4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Trailing Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Upper Control Arm - Front5 specs
- Control Arm BoltsTorque with weight on wheels119 lb-ft161 Nm
- Strut Bolts106 lb-ft144 Nm
- Sway Bar Link56 lb-ft76 Nm
- Upper Ball Joint NutUse new cotter pin81 lb-ft110 Nm
- Wheel Lug NutsTorque in star pattern135 lb-ft183 Nm
Steering
Center Link/Drag Link6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Idler Arm6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Pitman Arm6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Fluid Flush6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Gear Box8 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Pressure Line FittingNew O-ring31 lb-ft42 Nm
- Pump Mounting Bolts25 lb-ft34 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Hose - High Pressure6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Hose - Return6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Pump8 specs
- High Pressure Hose FittingUse new O-rings18 lb-ft25 Nm
- Power Steering Pump Bolts18 lb-ft25 Nm
- Pressure Line FittingUse new O-rings22 lb-ft30 Nm
- Pulley NutHold pulley with pin spanner52 lb-ft70 Nm
- Pump Mounting Bolts18 lb-ft25 Nm
- Return Hose Clamp2 lb-ft3 Nm
- Return Line Clamp3 lb-ft4 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Power Steering Pump Pulley6 specs
- Coupling Bolt31 lb-ft42 Nm
- Pressure Line FittingNew O-ring31 lb-ft42 Nm
- Pump Mounting Bolts25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Power Steering Reservoir5 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Rack and Pinion Boots4 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Angle Sensor4 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Column6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Coupler5 specs
- Coupling Bolt31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Damper4 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Shaft - Intermediate5 specs
- Coupling Bolt31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Shaft - Upper4 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Steering Wheel6 specs
- Coupling Bolt31 lb-ft42 Nm
- Power Steering Line FittingsUse new O-rings31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Tie Rod Assembly5 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Lock NutAfter alignment63 lb-ft85 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Tie Rod End - Inner6 specs
- Coupling Bolt31 lb-ft42 Nm
- Steering Rack Bolts94 lb-ft127 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Lock NutAfter alignment63 lb-ft85 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Tie Rod End - Outer5 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Lock NutAfter alignment63 lb-ft85 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Tie Rods - Both Sides5 specs
- Coupling Bolt31 lb-ft42 Nm
- Tie Rod End NutUse new cotter pin65 lb-ft88 Nm
- Tie Rod Lock NutAfter alignment63 lb-ft85 Nm
- Tie Rod Nut50 lb-ft68 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Drivetrain
Axle Seal - Front6 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
CV Axle - Front7 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Lower Ball Joint Nut94 lb-ft127 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
CV Axle - Rear5 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
CV Axles - Front Pair6 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Lower Ball Joint Nut94 lb-ft127 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
CV Boot - Inner5 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
CV Boot - Outer5 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Cover Gasket5 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Fluid Change - Front6 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Fluid Change - Rear5 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Pinion Seal5 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Rebuild - Front8 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Drain PlugNew washer38 lb-ft51 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Fill Plug38 lb-ft51 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Differential Rebuild - Rear7 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Drain PlugNew washer38 lb-ft51 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Fill Plug38 lb-ft51 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Driveshaft - Front3 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts (CV/U-Joint)Use new bolts if torque-to-yield55 lb-ft75 Nm
- Transfer Case Output Yoke NutIf accessible133 lb-ft180 Nm
Driveshaft - Rear3 specs
- Differential Pinion Yoke NutUse new nut, set pinion preload184 lb-ft250 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
- U-Joint Strap BoltsApply threadlocker26 lb-ft35 Nm
Driveshaft Center Support Bearing2 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
Front Differential6 specs
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Limited Slip Clutch Pack6 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Rear Differential5 specs
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Ring and Pinion6 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Transfer Case Fluid Change2 specs
- Transfer Case Drain Plug18 lb-ft25 Nm
- Transfer Case Fill Plug18 lb-ft25 Nm
U-Joint6 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Wheel Bearing - Press-In Front6 specs
- ABS Sensor Bolt10 lb-ft14 Nm
- Axle NutUse new nut, stake after199 lb-ft270 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Hub Bolts94 lb-ft127 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Wheel Bearing - Press-In Rear6 specs
- ABS Sensor Bolt10 lb-ft14 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Differential Cover BoltsApply RTV sealant31 lb-ft42 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Hub Bolts94 lb-ft127 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Wheel Bearing Hub - Front4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Axle NutUse new cotter pin after torque199 lb-ft270 Nm
- Caliper Bracket Bolts88 lb-ft120 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified81 lb-ft110 Nm
Wheel Bearing Hub - Rear2 specs
- Caliper Bracket Bolts81 lb-ft110 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified74 lb-ft100 Nm
Wheel Studs5 specs
- Axle NutUse new nut, stake after225 lb-ft305 Nm
- CV Bolts56 lb-ft76 Nm
- CV Joint Bolts56 lb-ft76 Nm
- Driveshaft Bolts69 lb-ft94 Nm
- Wheel Lug Nuts135 lb-ft183 Nm
Transmission
Neutral Safety Switch2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Overdrive Solenoid2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Pressure Plate2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Shift Cable2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Shift Fork2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Shift Linkage2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Synchros - All2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Synchros - Single Gear2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Control Module2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Cooler Lines2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Filter2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Filter and Fluid2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Fluid Change5 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Filter BoltsIf equipped with bolted filter6 lb-ft8 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Flush2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Input Shaft Bearing2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Oil Cooler7 specs
- Drain PetcockHand tight6 lb-ft8 Nm
- Drain PlugUse new washer31 lb-ft42 Nm
- Fan Bolts10 lb-ft14 Nm
- Fill Plug31 lb-ft42 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence22 lb-ft30 Nm
- Thermostat Housing Bolt12 lb-ft16 Nm
Transmission Output Shaft Bearing2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Pan Gasket2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission R&R - Automatic2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Range Sensor2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Rebuild - Automatic2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Speed Sensor - Input2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Transmission Speed Sensor - Output2 specs
- Drain PlugUse new washer31 lb-ft42 Nm
- Fill Plug31 lb-ft42 Nm
Exhaust
Catalytic Converter - Direct Fit4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Catalytic Converter - Universal4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
DEF Injector3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
DEF Tank3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Diesel Particulate Filter4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Downpipe4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
DPF Delete Pipe4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
EGR Cooler4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
EGR Tube3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
EGR Valve4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Exhaust Clamp3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Exhaust Gasket - Front4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Exhaust Gasket - Rear3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Exhaust Hangers3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Exhaust Manifold Studs4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Exhaust Pipe - Rear Section3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Exhaust Tip2 specs
- Hanger Bolts19 lb-ft26 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Flex Pipe4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Front Pipe4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Intermediate Pipe4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Muffler2 specs
- Hanger Bracket Bolts18 lb-ft25 Nm
- Muffler Clamps41 lb-ft55 Nm
O2 Sensor - Downstream4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
O2 Sensor - Upstream4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
O2 Sensors - All4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Resonator4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
SCR Catalyst4 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
- O2 SensorApply anti-seize to threads44 lb-ft60 Nm
Tail Pipe3 specs
- Hanger Bolts19 lb-ft26 Nm
- Heat Shield Bolts12 lb-ft16 Nm
- Manifold NutsApply anti-seize31 lb-ft42 Nm
Heating and A/C
AC Accumulator5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Clutch Coil4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Compressor3 specs
- AC Compressor Bolts18 lb-ft25 Nm
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Clutch Connector Bolt6 lb-ft8 Nm
AC Compressor Clutch4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Compressor Oil Add5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Condenser2 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Condenser Mounting Bolts9 lb-ft12 Nm
AC Evaporator7 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw4 lb-ft5 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Evaporator Case Screws6 lb-ft8 Nm
- Expansion Valve FittingUse new O-rings10 lb-ft14 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Expansion Valve (TXV)5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC High Pressure Switch5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Hose - High Side5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Hose - Low Side5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Hose Assembly5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Low Pressure Switch5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Orifice Tube5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Pressure Sensor5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Receiver/Drier5 specs
- AC Line FittingsNew O-rings19 lb-ft25 Nm
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
AC Recharge4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
Blend Door Actuator4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
Cabin Air Filter4 specs
- Compressor Bolts31 lb-ft42 Nm
- Connector Bolts6 lb-ft8 Nm
- Filter Cover ClipsTool-free on most2 lb-ft3 Nm
- Glove Box Screws4 lb-ft5 Nm
Climate Control Module4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
HVAC Control Panel4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
Mode Door Actuator4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
Recirculation Door Actuator4 specs
- Blower Motor Mounting Screw6 lb-ft8 Nm
- Compressor Bolts31 lb-ft42 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts22 lb-ft30 Nm
Body
Bed Rail Cap5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bedside Panel5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Cover - Front5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Cover - Rear5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Reinforcement - Front5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Reinforcement - Rear5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Check/Stop5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Glass5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Exterior5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Interior5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Hinge5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Shell5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Skin5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Weatherstrip5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender Liner5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Grille5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Hinge5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Latch5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Release Cable5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Strut5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Glass5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Panel5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Rear Window5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Rocker Panel5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Side Mirror Glass5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Tailgate5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Tailgate Cable5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Tailgate Handle5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Tonneau Cover Install5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Truck Bed Liner5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield Molding5 specs
- Hinge Bolts25 lb-ft34 Nm
- Latch Bolts12 lb-ft16 Nm
- Panel Bolts12 lb-ft16 Nm
- Striker Bolts31 lb-ft42 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Interior
Armrest1 spec
- Connector Bolts6 lb-ft8 Nm
Carpet1 spec
- Connector Bolts6 lb-ft8 Nm
Center Console1 spec
- Connector Bolts6 lb-ft8 Nm
Dash Pad1 spec
- Connector Bolts6 lb-ft8 Nm
Dashboard1 spec
- Connector Bolts6 lb-ft8 Nm
Door Panel1 spec
- Connector Bolts6 lb-ft8 Nm
Floor Mat Hooks1 spec
- Connector Bolts6 lb-ft8 Nm
Glove Box1 spec
- Connector Bolts6 lb-ft8 Nm
Glove Box Latch1 spec
- Connector Bolts6 lb-ft8 Nm
Headliner1 spec
- Connector Bolts6 lb-ft8 Nm
Pedal Pads1 spec
- Connector Bolts6 lb-ft8 Nm
Rearview Mirror1 spec
- Connector Bolts6 lb-ft8 Nm
Seat - Front1 spec
- Connector Bolts6 lb-ft8 Nm
Seat - Rear1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Belt1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Belt Buckle1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Belt Pretensioner1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Cover1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Foam1 spec
- Connector Bolts6 lb-ft8 Nm
Seat Track1 spec
- Connector Bolts6 lb-ft8 Nm
Shifter Boot1 spec
- Connector Bolts6 lb-ft8 Nm
Shifter Knob1 spec
- Connector Bolts6 lb-ft8 Nm
Steering Wheel Cover1 spec
- Connector Bolts6 lb-ft8 Nm
Sun Visor1 spec
- Connector Bolts6 lb-ft8 Nm
Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.
Need labor times, fluids or repair steps for this car? See it on the Open Labor Project