RQUE SPECS2024 Jeep Wrangler Rubicon 392 torque specs
6.4L V8
Change vehicle
Most looked up
- Lug nuts105 lb-ft142.4 Nm
- Oil drain plug20 lb-ft27 Nm
- Spark plugs15 lb-ft20 Nm
- Front caliper bracket bolts88 lb-ft120 Nm
- Rear caliper bracket bolts74 lb-ft100 Nm
- Front axle nut243 lb-ft329 Nm
- Outer tie rod end nut54 lb-ft73 Nm
Maintenance
AC System Diagnosis2 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Connector Bolts7 lb-ft9 Nm
Air Filter3 specs
- Intake Tube Clamp4 lb-ft5 Nm
- MAF Sensor Screws4 lb-ft5 Nm
- Mass Air Flow Sensor Screws2 lb-ft3 Nm
Battery Test4 specs
- Battery Hold-Down BoltDo not overtighten11 lb-ft15 Nm
- Battery Terminal BoltsClean terminals7 lb-ft9 Nm
- Connector Bolts7 lb-ft9 Nm
- Ground Cable Bolt14 lb-ft18 Nm
Charging System Test1 spec
- Connector Bolts7 lb-ft9 Nm
Check Engine Light Diagnosis1 spec
- Connector Bolts7 lb-ft9 Nm
Compression Test1 spec
- Connector Bolts7 lb-ft9 Nm
Cooling System Pressure Test1 spec
- Connector Bolts7 lb-ft9 Nm
Diagnostic Scan1 spec
- Connector Bolts7 lb-ft9 Nm
Differential Service3 specs
- Connector Bolts7 lb-ft9 Nm
- Drain PlugNew washer41 lb-ft55 Nm
- Fill Plug41 lb-ft55 Nm
Drivability Diagnosis1 spec
- Connector Bolts7 lb-ft9 Nm
Electrical Diagnosis1 spec
- Connector Bolts7 lb-ft9 Nm
Fluid Leak Diagnosis1 spec
- Connector Bolts7 lb-ft9 Nm
Leak-Down Test1 spec
- Connector Bolts7 lb-ft9 Nm
Noise Diagnosis1 spec
- Connector Bolts7 lb-ft9 Nm
Power Steering Service3 specs
- Connector Bolts7 lb-ft9 Nm
- Pressure Line FittingNew O-ring34 lb-ft46 Nm
- Pump Mounting Bolts27 lb-ft37 Nm
Tire Balance1 spec
- Connector Bolts7 lb-ft9 Nm
Tire Mount and Balance1 spec
- Connector Bolts7 lb-ft9 Nm
Tire Rotation2 specs
- Lug Nuts - Alloy WheelsTorque in star pattern, recheck after 50 miles130 lb-ft176 Nm
- Lug Nuts - Steel WheelsTorque in star pattern130 lb-ft176 Nm
TPMS Relearn1 spec
- Connector Bolts7 lb-ft9 Nm
TPMS Sensor3 specs
- Connector Bolts7 lb-ft9 Nm
- TPMS Sensor NutUse TPMS torque wrench5 lb-ft7 Nm
- Wheel Lug Nuts130 lb-ft176 Nm
Transmission Service1 spec
- Connector Bolts7 lb-ft9 Nm
Tune-Up - Major1 spec
- Connector Bolts7 lb-ft9 Nm
Tune-Up - Minor1 spec
- Connector Bolts7 lb-ft9 Nm
Wheel Alignment4 specs
- Cam BoltsAfter adjustment95 lb-ft129 Nm
- Connector Bolts7 lb-ft9 Nm
- Subframe BoltsIf adjusted115 lb-ft156 Nm
- Tie Rod Lock NutAfter adjustment50 lb-ft68 Nm
Brakes
ABS Module3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
ABS Pump3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
ABS Tone Ring3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
ABS Wheel Speed Sensor - Front3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
ABS Wheel Speed Sensor - Rear3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Bleed - All Four3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Booster3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Booster Check Valve3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper - Front3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
Brake Caliper - Rear3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
Brake Caliper Bracket4 specs
- Bleeder Screw14 lb-ft19 Nm
- Brake Hose Banjo BoltNew copper washers41 lb-ft55 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper Rebuild - Front3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper Rebuild - Rear3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Caliper Slide Pins3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Fluid Flush5 specs
- Bleeder ScrewFront and rear14 lb-ft19 Nm
- Caliper Mounting Bolts88 lb-ft119 Nm
- Connector Bolts7 lb-ft9 Nm
- Master Cylinder CapHand tight4 lb-ft5 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Brake Hose - Front3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Hose - Rear3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Light Switch3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Line - Single3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Lines - Complete Set3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Master Cylinder2 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Nuts18 lb-ft25 Nm
Brake Master Cylinder Rebuild3 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Mounting Nuts18 lb-ft25 Nm
- Reservoir Mounting Bolts6 lb-ft8 Nm
Brake Pads - Front3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern130 lb-ft176 Nm
Brake Pads - Rear3 specs
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
- Caliper Slide Pin BoltsApply silicone brake grease22 lb-ft30 Nm
- Wheel Lug NutsTorque in star pattern130 lb-ft176 Nm
Brake Pads and Rotors - Front5 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Bracket BoltsUse thread locker101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Caliper Slide BoltsLubricate pins34 lb-ft46 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Pads and Rotors - Rear5 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Bracket BoltsUse thread locker101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Caliper Slide BoltsLubricate pins34 lb-ft46 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Proportioning Valve3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotor - Front Single6 specs
- Bleeder Screw14 lb-ft19 Nm
- Brake Rotor Set Screw7 lb-ft9 Nm
- Caliper Bracket Bolts101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Hub NutIf removed243 lb-ft329 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotor - Rear Single6 specs
- Bleeder Screw14 lb-ft19 Nm
- Brake Rotor Set Screw7 lb-ft9 Nm
- Caliper Bracket Bolts101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Hub NutIf removed243 lb-ft329 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotors - Front Pair6 specs
- Bleeder Screw14 lb-ft19 Nm
- Brake Rotor Set Screw7 lb-ft9 Nm
- Caliper Bracket Bolts101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Hub NutIf removed243 lb-ft329 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Brake Rotors - Rear Pair6 specs
- Bleeder Screw14 lb-ft19 Nm
- Brake Rotor Set Screw7 lb-ft9 Nm
- Caliper Bracket Bolts101 lb-ft137 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Hub NutIf removed243 lb-ft329 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Electronic Parking Brake Motor3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Front Brake Pad Replacement3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern130 lb-ft176 Nm
Parking Brake Actuator3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Parking Brake Cable3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Parking Brake Shoes3 specs
- Bleeder Screw14 lb-ft19 Nm
- Caliper Mounting BoltsUse thread locker88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Engine
Camshaft Position Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Camshaft R&R3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Connecting Rod Bearings3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Crankshaft Position Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Crankshaft R&R3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Cylinder Head R&R3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Cylinder Head Resurface3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Engine Mount - Front3 specs
- Engine Mount Through-Bolt63 lb-ft85 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
Engine Mount - Rear5 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Engine Mount Through-Bolt88 lb-ft119 Nm
- Engine Mount-to-Frame Bolts61 lb-ft82 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Engine Mounts - All5 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Engine Mount Through-Bolt88 lb-ft119 Nm
- Engine Mount-to-Frame Bolts61 lb-ft82 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Engine R&R3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Engine Rebuild3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Exhaust Manifold8 specs
- EGR Tube Fitting35 lb-ft47 Nm
- Electrical Connector Bolts7 lb-ft9 Nm
- Exhaust Manifold NutsApply anti-seize25 lb-ft34 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Exhaust Manifold Gasket3 specs
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Exhaust Manifold StudsIf replacing studs11 lb-ft15 Nm
- Heat Shield Bolts7 lb-ft10 Nm
Fan Belt Replacement3 specs
- Idler Pulley Bolt30 lb-ft40 Nm
- Tensioner Bolt18 lb-ft25 Nm
- Tensioner Pulley Bolt33 lb-ft45 Nm
Flexplate3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Freeze Plug - Single3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Freeze Plugs - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Front Main Seal3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Full Engine Tune-Up5 specs
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Spark Plugs - Cast Iron HeadApply anti-seize to threads22 lb-ft30 Nm
- Throttle Body Bolts7 lb-ft10 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Harmonic Balancer3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Head Gasket - Single6 specs
- Exhaust Manifold NutsApply anti-seize18 lb-ft25 Nm
- Intake Manifold BoltTighten in sequence18 lb-ft25 Nm
- Cylinder Head Bolts - Step 1Always use new TTY bolts30 lb-ft40 Nm
- Cylinder Head Bolts - Step 2Tighten in sequence59 lb-ft80 Nm
- Cylinder Head Bolts - Step 3Plus 90 degreesTurn 90°
- Cylinder Head Bolts - Step 4Plus 90 degreesTurn 90°
Head Gaskets - Both8 specs
- Camshaft Cap BoltsTorque sequence16 lb-ft22 Nm
- Cylinder Head BoltsMulti-step + angle88 lb-ft119 Nm
- Electrical Connector Bolts7 lb-ft9 Nm
- Exhaust Manifold Nuts34 lb-ft46 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Intake Manifold Bolt24 lb-ft33 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
- Valve Cover Bolts14 lb-ft18 Nm
Idle Air Control Valve3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Idler Pulley3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Intake Manifold6 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Intake Manifold BoltTorque sequence24 lb-ft33 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
- Throttle Body Bolts14 lb-ft18 Nm
Intake Manifold Gasket3 specs
- Fuel Rail Bolts9 lb-ft12 Nm
- Intake Manifold BoltTighten in sequence from center out18 lb-ft25 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Knock Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Lifter - Single3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Lifters/Tappets - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Long Block Replacement3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Main Bearings3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Manifold Absolute Pressure Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Mass Air Flow Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Oil Change2 specs
- Oil Drain PlugUse new crush washer20 lb-ft27 Nm
- Oil Filter Housing CapFor cartridge-type filters18 lb-ft25 Nm
Oil Level Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Oil Pan Gasket2 specs
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence from center outward9 lb-ft12 Nm
Oil Pan Replacement3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Oil Pressure Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Oil Pump3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
PCV Valve3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Piston - Single3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Piston Rings - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Pistons - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Rear Main Seal3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Rocker Arms - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Serpentine Belt2 specs
- Belt Tensioner Bolt41 lb-ft55 Nm
- Idler Pulley Bolt33 lb-ft45 Nm
Serpentine Belt Tensioner3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Short Block Replacement3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Throttle Body2 specs
- Air Intake Hose Clamps2 lb-ft3 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Throttle Position Sensor3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Timing Chain5 specs
- Camshaft Sprocket Bolts59 lb-ft80 Nm
- Crankshaft Pulley BoltOften TTY - check specs133 lb-ft + 90°180 Nm
- Timing Chain Guide Bolts9 lb-ft12 Nm
- Timing Chain Tensioner18 lb-ft25 Nm
- Timing Cover BoltTighten in sequence9 lb-ft12 Nm
Timing Chain Guide1 spec
- Guide bolts20 lb-ft27 Nm
Timing Chain Kit3 specs
- Camshaft Sprocket Bolts90 lb-ft122 Nm
- Crankshaft damper bolt130 lb-ft176 Nm
- Tensioner/guide bolts20 lb-ft27 Nm
Timing Chain Tensioner1 spec
- Tensioner mounting bolts20 lb-ft27 Nm
Transmission Mount4 specs
- Crossmember Bolt70 lb-ft95 Nm
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
- Transmission Mount Bolts48 lb-ft65 Nm
Valve Adjustment3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Valve Cover Gasket - Single2 specs
- Spark Plug Tube SealsIf equipped with separate seals9 lb-ft12 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Cover Gaskets - Both5 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Ignition Coil Bolt11 lb-ft15 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
- Valve Cover BoltsDo not overtighten14 lb-ft18 Nm
Valve Job - Complete3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Valve Seals3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Valve Spring - Single3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Valve Springs - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Variable Valve Timing Actuator3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
VVT Solenoid - Single3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
VVT Solenoids - All3 specs
- Electrical Connector Bolts7 lb-ft9 Nm
- Gasket Surface BoltsClean mating surfaces20 lb-ft27 Nm
- Sensor Mounting Bolts11 lb-ft15 Nm
Cooling
Coolant Bypass Pipe6 specs
- Bleed ScrewOpen during fill7 lb-ft9 Nm
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Coolant Flush8 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Block Drain PlugIf equipped, use new washer18 lb-ft25 Nm
- Connector Bolts7 lb-ft9 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps4 lb-ft5 Nm
- Pump Bolts24 lb-ft33 Nm
- Radiator CapHand tight1 lb-ft1 Nm
Coolant Reservoir6 specs
- Bleed ScrewOpen during fill7 lb-ft9 Nm
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Coolant Temperature Sensor6 specs
- Bleed ScrewOpen during fill7 lb-ft9 Nm
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Cooling Fan Assembly5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Cooling Fan Clutch5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Cooling Fan Motor5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Cooling Fan Relay5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Engine Oil Cooler5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Heater Control Valve5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Heater Core5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Heater Hoses5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Radiator4 specs
- Drain PetcockPlastic - hand tight4 lb-ft5 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped18 lb-ft25 Nm
- Upper/Lower Hose Clamps2 lb-ft3 Nm
Radiator Cap5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Radiator Hose - Lower5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Radiator Hose - Upper5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Radiator Hoses - Both5 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Radiator Removal and Service4 specs
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
- Fan Shroud Bolts7 lb-ft10 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped, use new washers18 lb-ft25 Nm
Thermostat2 specs
- Coolant Temperature SensorUse thread sealant15 lb-ft20 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Thermostat Housing6 specs
- Coolant Hose Clamps4 lb-ft5 Nm
- Drain PetcockHand tight7 lb-ft9 Nm
- Fan Bolts11 lb-ft15 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Water Pump3 specs
- Hose ClampsSpring clamps preferred2 lb-ft3 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Ignition
Ignition Coil - Single1 spec
- Connector Bolts7 lb-ft9 Nm
Ignition Coils - All1 spec
- Connector Bolts7 lb-ft9 Nm
Ignition Control Module1 spec
- Connector Bolts7 lb-ft9 Nm
Ignition Lock Cylinder1 spec
- Connector Bolts7 lb-ft9 Nm
Ignition Switch1 spec
- Connector Bolts7 lb-ft9 Nm
Spark Plugs6 specs
- Connector Bolts7 lb-ft9 Nm
- Engine Cover Clips3 lb-ft4 Nm
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark PlugGap before install20 lb-ft27 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads15 lb-ft20 Nm
- Spark Plugs - Cast Iron HeadApply anti-seize to threads22 lb-ft30 Nm
Fuel system
Charcoal Canister4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
EVAP Purge Valve4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
EVAP Vent Valve4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Cap4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Filler Neck4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Filter4 specs
- Connector Bolts7 lb-ft9 Nm
- Filter Bracket Bolt14 lb-ft18 Nm
- Fuel Filter Bracket Bolt7 lb-ft10 Nm
- Fuel Line FittingsIf threaded type18 lb-ft25 Nm
Fuel Filter - In-Tank6 specs
- Filter Bracket11 lb-ft15 Nm
- Filter Bracket Bolt14 lb-ft18 Nm
- Fuel Line FittingsNew O-rings27 lb-ft37 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Injector - Single4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Injector Cleaning4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Injectors - All4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Level Sensor4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Line - High Pressure4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Line - Return4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Pressure Regulator4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Pump2 specs
- Fuel Pump Module Lock RingUse special tool59 lb-ft80 Nm
- Tank Strap Bolts26 lb-ft35 Nm
Fuel Pump Module6 specs
- Access Cover Screws4 lb-ft5 Nm
- Filter Bracket11 lb-ft15 Nm
- Fuel Pump Lock RingLock ring tool68 lb-ft92 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Rail4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Tank4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Fuel Tank Strap4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
High Pressure Fuel Pump4 specs
- Filter Bracket11 lb-ft15 Nm
- Fuel Rail Bolts20 lb-ft27 Nm
- Pressure Regulator Screws7 lb-ft9 Nm
- Pump Mounting14 lb-ft19 Nm
Electrical
Airbag - Driver3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Airbag - Passenger3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Airbag - Side3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Airbag Module/Computer3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Alternator4 specs
- Alternator Mounting Bolts37 lb-ft50 Nm
- Alternator Pivot Bolt18 lb-ft25 Nm
- Battery Terminal BoltsDo not overtighten6 lb-ft8 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Alternator Belt6 specs
- Alternator Mounting Bolts47 lb-ft64 Nm
- Alternator Pivot Bolt47 lb-ft64 Nm
- Battery Cable Nut14 lb-ft18 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Amplifier3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Antenna3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Backup Camera3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Battery3 specs
- Battery Hold-Down Bolt6 lb-ft8 Nm
- Battery Terminal BoltsDo not overtighten - can crack terminal4 lb-ft6 Nm
- Battery Tray Bolts9 lb-ft12 Nm
Battery Cable - Negative5 specs
- Battery Hold-Down BoltDo not overtighten11 lb-ft15 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt14 lb-ft18 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Battery Cable - Positive5 specs
- Battery Hold-Down BoltDo not overtighten11 lb-ft15 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt14 lb-ft18 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Battery Cables - Both5 specs
- Battery Hold-Down BoltDo not overtighten11 lb-ft15 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt14 lb-ft18 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Battery Terminal5 specs
- Battery Hold-Down BoltDo not overtighten11 lb-ft15 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Cable Bolt14 lb-ft18 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Blower Motor2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Blower Motor Resistor Screws1.5 lb-ft2 Nm
Blower Motor Control Module3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Blower Motor Resistor3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Clock Spring3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Combination Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Dimmer Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Door Lock Actuator - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Door Lock Actuator - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Fog Light Assembly3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Fog Light Bulb3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Fuel Pump Relay5 specs
- Access Cover Screws4 lb-ft5 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Fuel Pump Lock RingLock ring tool68 lb-ft92 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Fuse Box - Engine Bay3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Fuse Box - Interior3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Headlight Assembly3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Headlight Bulb - Single3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Headlight Bulbs - Pair3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Headlight Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Heated Seat Module3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
HID Ballast3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Horn3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Horn Relay3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Instrument Cluster3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
LED Headlight Module3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Main Relay3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Antenna Motor3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Mirror Motor3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Seat Motor3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Window Motor - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Window Motor - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Window Regulator - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Power Window Regulator - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Radio/Head Unit3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Relay - Generic3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Seat Heater Element3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Side Mirror Assembly3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Speaker - Dash3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Speaker - Door3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Speedometer3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Starter3 specs
- Heat Shield BoltsIf equipped7 lb-ft10 Nm
- Starter Mounting BoltLong bolt may need extension37 lb-ft50 Nm
- Starter Solenoid NutFor B+ cable9 lb-ft12 Nm
Starter Solenoid5 specs
- Battery Cable Nut14 lb-ft18 Nm
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
- Starter Mounting Bolt47 lb-ft64 Nm
Subwoofer3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Sunroof Motor3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Sunroof Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Tail Light Assembly3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Tail Light Bulb3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Third Brake Light3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Trunk/Liftgate Actuator3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Turn Signal Bulb - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Turn Signal Bulb - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Turn Signal Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Voltage Regulator3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Washer Pump3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Washer Reservoir3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Window Motor and Regulator - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Window Motor and Regulator - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Wiper Linkage3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Wiper Motor - Front3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Wiper Motor - Rear3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Wiper Switch3 specs
- Battery Terminal Bolts7 lb-ft9 Nm
- Connector Screws4 lb-ft5 Nm
- Ground Strap BoltsClean contact surfaces14 lb-ft19 Nm
Suspension
Ball Joint - Lower8 specs
- Ball Joint Pinch BoltUse new bolt45 lb-ft61 Nm
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Lower Ball Joint Castle NutUse new cotter pin75 lb-ft102 Nm
- Lower Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Pinch BoltNew bolt61 lb-ft82 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug Nuts130 lb-ft176 Nm
Ball Joint - Upper6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Pinch BoltNew bolt61 lb-ft82 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Upper Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Ball Joints - Upper and Lower7 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Lower Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Pinch BoltNew bolt61 lb-ft82 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Upper Ball Joint NutUse new cotter pin87.8 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Coil Spring - Front4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Coil Spring - Rear3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Coil Springs - Front Pair4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Coil Springs - Rear Pair3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Control Arm Bushing - Front Lower5 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Lower Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Control Arm Bushing - Front Upper1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Control Arm Bushing - Rear3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Front Struts - Pair6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Strut to Knuckle Bolts122 lb-ft165 Nm
- Strut Tower Nuts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Front Suspension Rebuild4 specs
- Ball Joint Pinch BoltUse new bolt if locknut style37 lb-ft50 Nm
- Lower Control Arm BoltsTorque at ride height81 lb-ft110 Nm
- Strut Top Mount Nuts18 lb-ft25 Nm
- Sway Bar End Link Nuts44 lb-ft60 Nm
Knuckle/Spindle - Front6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Lower Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Upper Ball Joint NutUse new cotter pin87.8 lb-ft119 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Knuckle/Spindle - Rear1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Lateral Arm4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Lower Control Arm - Front5 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Lower Ball Joint NutUse new cotter pin88 lb-ft119 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Lower Control Arm - Rear3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Panhard Bar/Track Bar4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Radius Arm4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Radius Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Rear Shocks - Pair3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Rear Suspension Service4 specs
- Lower Control Arm BoltsTorque at ride height66 lb-ft90 Nm
- Shock Lower Bolt52 lb-ft70 Nm
- Sway Bar End Link Nuts37 lb-ft50 Nm
- Trailing Arm BoltsTorque at ride height88 lb-ft120 Nm
Shock Absorber Replacement2 specs
- Lower Mount Bolt66 lb-ft90 Nm
- Upper Mount NutUse new self-locking nut41 lb-ft55 Nm
Strut Assembly - Rear1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Strut Bearing6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Strut to Knuckle Bolts122 lb-ft165 Nm
- Strut Tower Nuts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Strut Mount - Front6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Strut to Knuckle Bolts122 lb-ft165 Nm
- Strut Tower Nuts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Strut Mount - Rear1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Subframe4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Subframe Bushing4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar - Front6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar - Rear5 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar Bushing - Front6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar Bushing - Rear5 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar Link - Front6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar Link - Rear5 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Sway Bar Links - Front Pair6 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Bracket Bolts47 lb-ft64 Nm
- Sway Bar Link61 lb-ft83 Nm
- Sway Bar Link Nuts61 lb-ft82 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Torsion Bar4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Torsion Bar Adjustment4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Trailing Arm4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Trailing Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Strut Bolts115 lb-ft156 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Upper Control Arm - Front1 spec
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Upper Control Arm - Rear3 specs
- Control Arm BoltsTorque with weight on wheels128 lb-ft174 Nm
- Sway Bar Link61 lb-ft83 Nm
- Wheel Lug NutsTorque in star pattern105 lb-ft142.4 Nm
Steering
Power Steering Fluid Flush6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Hose - High Pressure6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Hose - Return6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Pump8 specs
- High Pressure Hose FittingUse new O-rings18 lb-ft25 Nm
- Power Steering Pump Bolts18 lb-ft25 Nm
- Pressure Line FittingUse new O-rings22 lb-ft30 Nm
- Pulley NutHold pulley with pin spanner52 lb-ft70 Nm
- Pump Mounting Bolts18 lb-ft25 Nm
- Return Hose Clamp2 lb-ft3 Nm
- Return Line Clamp3 lb-ft4 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Power Steering Pump Pulley8 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Pressure Line FittingNew O-ring34 lb-ft46 Nm
- Pump Mounting Bolts27 lb-ft37 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Rack8 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Pressure Line FittingNew O-ring34 lb-ft46 Nm
- Pump Mounting Bolts27 lb-ft37 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Power Steering Reservoir6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Rack and Pinion Boots6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Angle Sensor6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Column6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Coupler6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Damper6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Shaft - Intermediate6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Shaft - Upper6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Steering Wheel6 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod Assembly7 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Lock NutAfter alignment68 lb-ft92 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod End - Inner7 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Lock NutAfter alignment68 lb-ft92 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rod End - Outer7 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Lock NutAfter alignment68 lb-ft92 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Tie Rods - Both Sides7 specs
- Coupling Bolt34 lb-ft46 Nm
- Power Steering Line FittingsUse new O-rings34 lb-ft46 Nm
- Steering Rack Bolts101 lb-ft137 Nm
- Tie Rod End NutUse new cotter pin54 lb-ft73 Nm
- Tie Rod Lock NutAfter alignment68 lb-ft92 Nm
- Tie Rod Nut54 lb-ft73 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Drivetrain
Axle Seal - Front6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axle - Front7 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Lower Ball Joint Nut101 lb-ft137 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axle - Rear6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Axles - Front Pair7 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Lower Ball Joint Nut101 lb-ft137 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Boot - Inner6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
CV Boot - Outer6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Cover Gasket6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Fluid Change - Front6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Fluid Change - Rear6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Pinion Seal6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Rebuild - Front8 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Drain PlugNew washer41 lb-ft55 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Fill Plug41 lb-ft55 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Differential Rebuild - Rear8 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Drain PlugNew washer41 lb-ft55 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Fill Plug41 lb-ft55 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Driveshaft - Front3 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts (CV/U-Joint)Use new bolts if torque-to-yield55 lb-ft75 Nm
- Transfer Case Output Yoke NutIf accessible133 lb-ft180 Nm
Driveshaft - Rear3 specs
- Differential Pinion Yoke NutUse new nut, set pinion preload184 lb-ft250 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
- U-Joint Strap BoltsApply threadlocker26 lb-ft35 Nm
Driveshaft Center Support Bearing2 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
Front Differential6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Limited Slip Clutch Pack6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Rear Differential6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Ring and Pinion6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Transfer Case Fluid Change2 specs
- Transfer Case Drain Plug18 lb-ft25 Nm
- Transfer Case Fill Plug18 lb-ft25 Nm
U-Joint6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing - Press-In Front7 specs
- ABS Sensor Bolt11 lb-ft15 Nm
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Hub Bolts101 lb-ft137 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing - Press-In Rear7 specs
- ABS Sensor Bolt11 lb-ft15 Nm
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Hub Bolts101 lb-ft137 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Wheel Bearing Hub - Front4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Axle NutUse new cotter pin after torque184 lb-ft250 Nm
- Caliper Bracket Bolts88 lb-ft120 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified81 lb-ft110 Nm
Wheel Bearing Hub - Rear3 specs
- Axle NutUse new cotter pin after torque148 lb-ft200 Nm
- Caliper Bracket Bolts81 lb-ft110 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified74 lb-ft100 Nm
Wheel Studs6 specs
- Axle NutUse new nut, stake after243 lb-ft329 Nm
- CV Bolts61 lb-ft82 Nm
- CV Joint Bolts61 lb-ft83 Nm
- Differential Cover BoltsApply RTV sealant34 lb-ft46 Nm
- Driveshaft Bolts74 lb-ft100 Nm
- Wheel Lug Nuts105 lb-ft142.4 Nm
Transmission
Neutral Safety Switch2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Overdrive Solenoid2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Pressure Plate2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Shift Cable2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Shift Fork2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Shift Linkage2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Synchros - All2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Synchros - Single Gear2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Control Module2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Cooler Lines2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Filter2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Filter and Fluid2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Fluid Change5 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Filter BoltsIf equipped with bolted filter6 lb-ft8 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Flush2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Input Shaft Bearing2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Oil Cooler7 specs
- Drain PetcockHand tight7 lb-ft9 Nm
- Drain PlugUse new washer34 lb-ft46 Nm
- Fan Bolts11 lb-ft15 Nm
- Fill Plug34 lb-ft46 Nm
- Hose ClampsDo not overtighten4 lb-ft5 Nm
- Pump BoltsTorque in sequence24 lb-ft33 Nm
- Thermostat Housing Bolt14 lb-ft19 Nm
Transmission Output Shaft Bearing2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Pan Gasket2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission R&R - Automatic2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Range Sensor2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Rebuild - Automatic2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Speed Sensor - Input2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Transmission Speed Sensor - Output2 specs
- Drain PlugUse new washer34 lb-ft46 Nm
- Fill Plug34 lb-ft46 Nm
Exhaust
Catalytic Converter - Direct Fit4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Catalytic Converter - Universal4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Downpipe4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
EGR Tube4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
EGR Valve4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Clamp4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Gasket - Front4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Gasket - Rear4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Hangers4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Manifold Studs4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Pipe - Rear Section4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Exhaust Tip4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Flex Pipe4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Front Pipe4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Intermediate Pipe4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Muffler2 specs
- Hanger Bracket Bolts18 lb-ft25 Nm
- Muffler Clamps41 lb-ft55 Nm
O2 Sensor - Downstream4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
O2 Sensor - Upstream4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
O2 Sensors - All4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Resonator4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Tail Pipe4 specs
- Hanger Bolts20 lb-ft27 Nm
- Heat Shield Bolts14 lb-ft19 Nm
- Manifold NutsApply anti-seize34 lb-ft46 Nm
- O2 SensorApply anti-seize to threads47 lb-ft64 Nm
Heating and A/C
AC Accumulator5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Clutch Coil5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Compressor3 specs
- AC Compressor Bolts18 lb-ft25 Nm
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Clutch Connector Bolt6 lb-ft8 Nm
AC Compressor Clutch5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Compressor Oil Add5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Condenser2 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Condenser Mounting Bolts9 lb-ft12 Nm
AC Evaporator7 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Evaporator Case Screws5 lb-ft7 Nm
- Expansion Valve FittingUse new O-rings8 lb-ft11 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Expansion Valve (TXV)5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC High Pressure Switch5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Hose - High Side5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Hose - Low Side5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Hose Assembly5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Low Pressure Switch5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Orifice Tube5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Pressure Sensor5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Receiver/Drier5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
AC Recharge5 specs
- AC Line FittingsNew O-rings20 lb-ft27 Nm
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
Blend Door Actuator4 specs
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
Cabin Air Filter4 specs
- Compressor Bolts34 lb-ft46 Nm
- Connector Bolts7 lb-ft9 Nm
- Filter Cover ClipsTool-free on most3 lb-ft4 Nm
- Glove Box Screws4 lb-ft5 Nm
Climate Control Module4 specs
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
HVAC Control Panel4 specs
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
Mode Door Actuator4 specs
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
Recirculation Door Actuator4 specs
- Blower Motor Mounting Screw7 lb-ft9 Nm
- Compressor Bolts34 lb-ft46 Nm
- Duct Clips3 lb-ft4 Nm
- Mounting Bracket Bolts24 lb-ft33 Nm
Body
Bumper Cover - Front5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Bumper Cover - Rear5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Bumper Reinforcement - Front5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Bumper Reinforcement - Rear5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Check/Stop5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Glass5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Handle - Exterior5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Handle - Interior5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Hinge5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Shell5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Skin5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Door Weatherstrip5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Fender5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Fender Liner5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Grille5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Hood5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Hood Hinge5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Hood Latch5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Hood Release Cable5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Hood Strut5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Liftgate5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Liftgate Motor5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Liftgate Strut5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Quarter Glass5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Quarter Panel5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Rear Window5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Rocker Panel5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Side Mirror Glass5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Windshield5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Windshield Molding5 specs
- Hinge Bolts27 lb-ft37 Nm
- Latch Bolts14 lb-ft19 Nm
- Panel Bolts14 lb-ft19 Nm
- Striker Bolts34 lb-ft46 Nm
- Trim ClipsReplace if broken3 lb-ft4 Nm
Interior
Armrest1 spec
- Connector Bolts7 lb-ft9 Nm
Carpet1 spec
- Connector Bolts7 lb-ft9 Nm
Center Console1 spec
- Connector Bolts7 lb-ft9 Nm
Dash Pad1 spec
- Connector Bolts7 lb-ft9 Nm
Dashboard1 spec
- Connector Bolts7 lb-ft9 Nm
Door Panel1 spec
- Connector Bolts7 lb-ft9 Nm
Floor Mat Hooks1 spec
- Connector Bolts7 lb-ft9 Nm
Glove Box1 spec
- Connector Bolts7 lb-ft9 Nm
Glove Box Latch1 spec
- Connector Bolts7 lb-ft9 Nm
Headliner1 spec
- Connector Bolts7 lb-ft9 Nm
Pedal Pads1 spec
- Connector Bolts7 lb-ft9 Nm
Rearview Mirror1 spec
- Connector Bolts7 lb-ft9 Nm
Seat - Front1 spec
- Connector Bolts7 lb-ft9 Nm
Seat - Rear1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Belt1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Belt Buckle1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Belt Pretensioner1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Cover1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Foam1 spec
- Connector Bolts7 lb-ft9 Nm
Seat Track1 spec
- Connector Bolts7 lb-ft9 Nm
Shifter Boot1 spec
- Connector Bolts7 lb-ft9 Nm
Shifter Knob1 spec
- Connector Bolts7 lb-ft9 Nm
Steering Wheel Cover1 spec
- Connector Bolts7 lb-ft9 Nm
Sun Visor1 spec
- Connector Bolts7 lb-ft9 Nm
Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.
Need labor times, fluids or repair steps for this car? See it on the Open Labor Project