RQUE SPECS2014 Audi A5 torque specs
2.0L Turbo I4
Change vehicle
Most looked up
- Lug nuts89 lb-ft121 Nm
- Oil drain plug22 lb-ft30 Nm
- Spark plugs22 lb-ft30 Nm
- Front caliper bracket bolts88 lb-ft120 Nm
- Rear caliper bracket bolts74 lb-ft100 Nm
- Front axle nut180 lb-ft244 Nm
- Outer tie rod end nut40 lb-ft54 Nm
Maintenance
AC System Diagnosis2 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Connector Bolts5 lb-ft7 Nm
Air Filter3 specs
- Intake Tube Clamp3 lb-ft4 Nm
- MAF Sensor Screws3 lb-ft4 Nm
- Mass Air Flow Sensor Screws2 lb-ft3 Nm
Battery Test4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal BoltsClean terminals5 lb-ft7 Nm
- Connector Bolts5 lb-ft7 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Charging System Test1 spec
- Connector Bolts5 lb-ft7 Nm
Check Engine Light Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Compression Test1 spec
- Connector Bolts5 lb-ft7 Nm
Cooling System Pressure Test1 spec
- Connector Bolts5 lb-ft7 Nm
Diagnostic Scan1 spec
- Connector Bolts5 lb-ft7 Nm
Differential Service3 specs
- Connector Bolts5 lb-ft7 Nm
- Drain PlugNew washer30 lb-ft41 Nm
- Fill Plug30 lb-ft41 Nm
Drivability Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Electrical Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Fluid Leak Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Leak-Down Test1 spec
- Connector Bolts5 lb-ft7 Nm
Noise Diagnosis1 spec
- Connector Bolts5 lb-ft7 Nm
Power Steering Service3 specs
- Connector Bolts5 lb-ft7 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
Tire Balance1 spec
- Connector Bolts5 lb-ft7 Nm
Tire Mount and Balance1 spec
- Connector Bolts5 lb-ft7 Nm
Tire Rotation2 specs
- Lug Nuts - Alloy WheelsTorque in star pattern, recheck after 50 miles89 lb-ft121 Nm
- Lug Nuts - Steel WheelsTorque in star pattern89 lb-ft121 Nm
TPMS Relearn1 spec
- Connector Bolts5 lb-ft7 Nm
TPMS Sensor3 specs
- Connector Bolts5 lb-ft7 Nm
- TPMS Sensor NutUse TPMS torque wrench5 lb-ft7 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Transmission Service1 spec
- Connector Bolts5 lb-ft7 Nm
Tune-Up - Major1 spec
- Connector Bolts5 lb-ft7 Nm
Tune-Up - Minor1 spec
- Connector Bolts5 lb-ft7 Nm
Wheel Alignment4 specs
- Cam BoltsAfter adjustment95 lb-ft129 Nm
- Connector Bolts5 lb-ft7 Nm
- Subframe BoltsIf adjusted85 lb-ft115 Nm
- Tie Rod Lock NutAfter adjustment50 lb-ft68 Nm
Brakes
ABS Module3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
ABS Pump3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
ABS Tone Ring2 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
ABS Wheel Speed Sensor - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
ABS Wheel Speed Sensor - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Bleed - All Four3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Booster3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Booster Check Valve1 spec
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
Brake Caliper - Front3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
Brake Caliper - Rear3 specs
- Bleeder ScrewDo not overtighten7 lb-ft10 Nm
- Brake Line Banjo BoltUse new copper washers18 lb-ft25 Nm
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
Brake Caliper Bracket4 specs
- Bleeder Screw10 lb-ft14 Nm
- Brake Hose Banjo BoltNew copper washers30 lb-ft41 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Caliper Rebuild - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Caliper Rebuild - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Caliper Slide Pins2 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Fluid Flush5 specs
- Bleeder ScrewFront and rear10 lb-ft14 Nm
- Caliper Mounting Bolts65 lb-ft88 Nm
- Connector Bolts5 lb-ft7 Nm
- Master Cylinder CapHand tight3 lb-ft4 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Brake Hose - Front3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Hose - Rear3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Light Switch1 spec
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
Brake Line - Single3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Lines - Complete Set3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Master Cylinder2 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Nuts18 lb-ft25 Nm
Brake Master Cylinder Rebuild3 specs
- Brake Line FittingsUse flare nut wrench11 lb-ft15 Nm
- Master Cylinder Mounting Nuts18 lb-ft25 Nm
- Reservoir Mounting Bolts6 lb-ft8 Nm
Brake Pads - Front3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Pads - Rear3 specs
- Caliper Bracket BoltsThreadlocker recommended74 lb-ft100 Nm
- Caliper Slide Pin BoltsApply silicone brake grease22 lb-ft30 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Pads and Rotors - Front5 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Pads and Rotors - Rear5 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Bracket BoltsUse thread locker75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Caliper Slide BoltsLubricate pins25 lb-ft34 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Proportioning Valve3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Rotor - Front Single5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Rotor - Rear Single5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Rotors - Front Pair5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Brake Rotors - Rear Pair5 specs
- Brake Rotor Set Screw5 lb-ft7 Nm
- Caliper Bracket Bolts75 lb-ft102 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Hub NutIf removed180 lb-ft244 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Electronic Parking Brake Motor2 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Front Brake Pad Replacement3 specs
- Caliper Bracket BoltsThreadlocker recommended88 lb-ft120 Nm
- Caliper Slide Pin BoltsApply silicone brake grease26 lb-ft35 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Parking Brake Actuator2 specs
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Parking Brake Cable3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Parking Brake Shoes3 specs
- Bleeder Screw10 lb-ft14 Nm
- Caliper Mounting BoltsUse thread locker65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Engine
Boost Pressure Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Camshaft Position Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Camshaft R&R3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Connecting Rod Bearings3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Crankshaft Position Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Crankshaft R&R3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Cylinder Head R&R3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Cylinder Head Resurface3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Engine Mount - Front3 specs
- Engine Mount Through-Bolt63 lb-ft85 Nm
- Engine Mount-to-Block Bolts48 lb-ft65 Nm
- Engine Mount-to-Frame Bolts55 lb-ft75 Nm
Engine Mount - Rear5 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Engine Mount Through-Bolt65 lb-ft88 Nm
- Engine Mount-to-Frame Bolts45 lb-ft61 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Engine Mounts - All5 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Engine Mount Through-Bolt65 lb-ft88 Nm
- Engine Mount-to-Frame Bolts45 lb-ft61 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Engine R&R3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Engine Rebuild3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Exhaust Manifold8 specs
- EGR Tube Fitting35 lb-ft47 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Exhaust Manifold NutsApply anti-seize25 lb-ft34 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Exhaust Manifold Gasket3 specs
- Exhaust Manifold NutsApply anti-seize, work hot-to-cold22 lb-ft30 Nm
- Exhaust Manifold StudsIf replacing studs11 lb-ft15 Nm
- Heat Shield Bolts7 lb-ft10 Nm
Fan Belt Replacement3 specs
- Idler Pulley Bolt30 lb-ft40 Nm
- Tensioner Bolt18 lb-ft25 Nm
- Tensioner Pulley Bolt33 lb-ft45 Nm
Flexplate3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Flywheel4 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Flexplate BoltsAutomatic transmissions63 lb-ft85 Nm
- Flywheel BoltsOften TTY - check specs, tighten in star pattern70 lb-ft95 Nm
Freeze Plug - Single3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Freeze Plugs - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Front Main Seal3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Full Engine Tune-Up4 specs
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads22 lb-ft30 Nm
- Throttle Body Bolts7 lb-ft10 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Harmonic Balancer3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Head Gasket - Single6 specs
- Exhaust Manifold NutsApply anti-seize18 lb-ft25 Nm
- Intake Manifold BoltTighten in sequence18 lb-ft25 Nm
- Cylinder Head Bolts - Step 1Always use new TTY bolts30 lb-ft40 Nm
- Cylinder Head Bolts - Step 2Tighten in sequence59 lb-ft80 Nm
- Cylinder Head Bolts - Step 3Plus 90 degreesTurn 90°
- Cylinder Head Bolts - Step 4Plus 90 degreesTurn 90°
Head Gaskets - Both8 specs
- Camshaft Cap BoltsTorque sequence12 lb-ft16 Nm
- Cylinder Head BoltsMulti-step + angle30 lb-ft40 Nm
- Electrical Connector Bolts5 lb-ft7 Nm
- Exhaust Manifold Nuts25 lb-ft34 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Intake Manifold Bolt18 lb-ft24 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Valve Cover Bolts10 lb-ft14 Nm
Idle Air Control Valve3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Idler Pulley3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Intake Manifold6 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Intake Manifold BoltTorque sequence18 lb-ft24 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Throttle Body Bolts10 lb-ft14 Nm
Intake Manifold Gasket3 specs
- Fuel Rail Bolts9 lb-ft12 Nm
- Intake Manifold BoltTighten in sequence from center out18 lb-ft25 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Intercooler3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Knock Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Lifter - Single3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Lifters/Tappets - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Long Block Replacement3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Main Bearings3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Manifold Absolute Pressure Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Mass Air Flow Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Change2 specs
- Oil Drain PlugUse new crush washer22 lb-ft30 Nm
- Oil Filter Housing CapFor cartridge-type filters18 lb-ft25 Nm
Oil Level Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pan Gasket2 specs
- Oil Drain PlugUse new crush washer26 lb-ft35 Nm
- Oil Pan BoltTighten in sequence from center outward9 lb-ft12 Nm
Oil Pan Replacement3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pressure Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Oil Pump3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
PCV Valve3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Piston - Single3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Piston Rings - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Pistons - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Rear Main Seal3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Rocker Arms - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Serpentine Belt2 specs
- Belt Tensioner Bolt41 lb-ft55 Nm
- Idler Pulley Bolt33 lb-ft45 Nm
Serpentine Belt Tensioner3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Short Block Replacement3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Throttle Body2 specs
- Air Intake Hose Clamps2 lb-ft3 Nm
- Throttle Body Bolts7 lb-ft10 Nm
Throttle Position Sensor3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Timing Chain5 specs
- Camshaft Sprocket Bolts59 lb-ft80 Nm
- Crankshaft Pulley BoltOften TTY - check specs133 lb-ft + 90°180 Nm
- Timing Chain Guide Bolts9 lb-ft12 Nm
- Timing Chain Tensioner18 lb-ft25 Nm
- Timing Cover BoltTighten in sequence9 lb-ft12 Nm
Timing Chain Guide4 specs
- Camshaft Sprocket Bolts55 lb-ft75 Nm
- Chain Guide Bolts7 lb-ft9 Nm
- Crankshaft Pulley Bolt111 lb-ft150 Nm
- Tensioner Bolt15 lb-ft20 Nm
Timing Chain Kit5 specs
- Camshaft sprocket bolt (use new)55 lb-ft75 Nm
- Chain Guide Bolts7 lb-ft9 Nm
- Crankshaft pulley bolt (use new, +180°)111 lb-ft150 Nm
- Oil pump chain tensioner10 lb-ft14 Nm
- Tensioner Bolt15 lb-ft20 Nm
Timing Chain Tensioner3 specs
- Tensioner Cap/PlugUse new crush washer if equipped22 lb-ft30 Nm
- Tensioner Housing BoltsTighten in sequence18 lb-ft25 Nm
- Timing Cover Access Bolts9 lb-ft12 Nm
Transmission Mount4 specs
- Crossmember Bolt70 lb-ft95 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Mount Bolts48 lb-ft65 Nm
Turbo Wastegate Actuator3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Turbocharger3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Valve Adjustment3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Valve Cover Gasket - Single2 specs
- Spark Plug Tube SealsIf equipped with separate seals9 lb-ft12 Nm
- Valve Cover BoltsTighten in sequence7 lb-ft10 Nm
Valve Cover Gaskets - Both5 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Ignition Coil Bolt8 lb-ft11 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
- Valve Cover BoltsDo not overtighten10 lb-ft14 Nm
Valve Job - Complete3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Valve Seals3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Valve Spring - Single3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Valve Springs - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Variable Valve Timing Actuator3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
VVT Solenoid - Single3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
VVT Solenoids - All3 specs
- Electrical Connector Bolts5 lb-ft7 Nm
- Gasket Surface BoltsClean mating surfaces15 lb-ft20 Nm
- Sensor Mounting Bolts8 lb-ft11 Nm
Cooling
Coolant Bypass Pipe6 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Coolant Flush8 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Block Drain PlugIf equipped, use new washer18 lb-ft25 Nm
- Connector Bolts5 lb-ft7 Nm
- Coolant Hose Clamps3 lb-ft4 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Hose Clamps3 lb-ft4 Nm
- Pump Bolts18 lb-ft24 Nm
- Radiator CapHand tight1 lb-ft1 Nm
Coolant Reservoir6 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Coolant Temperature Sensor6 specs
- Bleed ScrewOpen during fill5 lb-ft7 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Cooling Fan Assembly5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Cooling Fan Clutch5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Cooling Fan Motor5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Cooling Fan Relay4 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Engine Oil Cooler5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Heater Control Valve5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Heater Core5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Heater Hoses5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Radiator4 specs
- Drain PetcockPlastic - hand tight4 lb-ft5 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped18 lb-ft25 Nm
- Upper/Lower Hose Clamps2 lb-ft3 Nm
Radiator Cap4 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Radiator Hose - Lower5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Radiator Hose - Upper5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Radiator Hoses - Both5 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Radiator Removal and Service4 specs
- Drain PetcockPlastic - hand-tight only4 lb-ft5 Nm
- Fan Shroud Bolts7 lb-ft10 Nm
- Radiator Mounting BoltDo not overtighten plastic mounts9 lb-ft12 Nm
- Transmission Cooler LinesIf equipped, use new washers18 lb-ft25 Nm
Thermostat2 specs
- Coolant Temperature SensorUse thread sealant15 lb-ft20 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
Thermostat Housing6 specs
- Coolant Hose Clamps3 lb-ft4 Nm
- Drain PetcockHand tight5 lb-ft7 Nm
- Fan Bolts8 lb-ft11 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Water Pump3 specs
- Hose ClampsSpring clamps preferred2 lb-ft3 Nm
- Thermostat Housing Bolt11 lb-ft15 Nm
- Water Pump BoltsTighten in criss-cross pattern18 lb-ft25 Nm
Ignition
Ignition Coil - Single1 spec
- Connector Bolts5 lb-ft7 Nm
Ignition Coils - All1 spec
- Connector Bolts5 lb-ft7 Nm
Ignition Control Module1 spec
- Connector Bolts5 lb-ft7 Nm
Ignition Lock Cylinder1 spec
- Connector Bolts5 lb-ft7 Nm
Ignition Switch1 spec
- Connector Bolts5 lb-ft7 Nm
Spark Plugs5 specs
- Connector Bolts5 lb-ft7 Nm
- Engine Cover Clips2 lb-ft3 Nm
- Ignition Coil Bolt6 lb-ft8 Nm
- Spark PlugGap before install22 lb-ft30 Nm
- Spark Plugs - Aluminum HeadApply anti-seize to threads22 lb-ft30 Nm
Fuel system
Charcoal Canister3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
EVAP Purge Valve3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
EVAP Vent Valve3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Cap3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Filler Neck4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Filter4 specs
- Connector Bolts5 lb-ft7 Nm
- Filter Bracket Bolt10 lb-ft14 Nm
- Fuel Filter Bracket Bolt7 lb-ft10 Nm
- Fuel Line FittingsIf threaded type18 lb-ft25 Nm
Fuel Filter - In-Tank5 specs
- Filter Bracket8 lb-ft11 Nm
- Filter Bracket Bolt10 lb-ft14 Nm
- Fuel Line FittingsNew O-rings20 lb-ft27 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Injector - Single4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Injector Cleaning4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Injectors - All4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Level Sensor3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Line - High Pressure4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Line - Return4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Pressure Regulator4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Pump2 specs
- Fuel Pump Module Lock RingUse special tool59 lb-ft80 Nm
- Tank Strap Bolts26 lb-ft35 Nm
Fuel Pump Module5 specs
- Access Cover Screws3 lb-ft4 Nm
- Filter Bracket8 lb-ft11 Nm
- Fuel Pump Lock RingLock ring tool50 lb-ft68 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Rail4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Tank4 specs
- Filter Bracket8 lb-ft11 Nm
- Fuel Rail Bolts15 lb-ft20 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Fuel Tank Strap3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
High Pressure Fuel Pump3 specs
- Filter Bracket8 lb-ft11 Nm
- Pressure Regulator Screws5 lb-ft7 Nm
- Pump Mounting10 lb-ft14 Nm
Electrical
Airbag - Driver3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Airbag - Passenger3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Airbag - Side3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Airbag Module/Computer2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Alternator4 specs
- Alternator Mounting Bolts37 lb-ft50 Nm
- Alternator Pivot Bolt18 lb-ft25 Nm
- Battery Terminal BoltsDo not overtighten6 lb-ft8 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Alternator Belt4 specs
- Alternator Mounting Bolts35 lb-ft47 Nm
- Alternator Pivot Bolt35 lb-ft47 Nm
- Battery Cable Nut10 lb-ft14 Nm
- Connector Screws3 lb-ft4 Nm
Amplifier3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Antenna2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Backup Camera2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Battery3 specs
- Battery Hold-Down Bolt6 lb-ft8 Nm
- Battery Terminal BoltsDo not overtighten - can crack terminal4 lb-ft6 Nm
- Battery Tray Bolts9 lb-ft12 Nm
Battery Cable - Negative5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Battery Cable - Positive4 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
Battery Cables - Both5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Battery Terminal5 specs
- Battery Hold-Down BoltDo not overtighten8 lb-ft11 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Cable Bolt10 lb-ft14 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Blower Motor2 specs
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Blower Motor Resistor Screws1.5 lb-ft2 Nm
Blower Motor Control Module2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Blower Motor Resistor3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Clock Spring3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Combination Switch2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Dimmer Switch2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Door Lock Actuator - Front2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Door Lock Actuator - Rear2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Fog Light Assembly2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Fog Light Bulb1 spec
- Connector Screws3 lb-ft4 Nm
Fuel Pump Relay5 specs
- Access Cover Screws3 lb-ft4 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Fuel Pump Lock RingLock ring tool50 lb-ft68 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Fuse Box - Engine Bay3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Fuse Box - Interior3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Headlight Assembly3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Headlight Bulb - Single3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Headlight Bulbs - Pair1 spec
- Connector Screws3 lb-ft4 Nm
Headlight Switch2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Heated Seat Module2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
HID Ballast2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Horn3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Horn Relay2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Instrument Cluster2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
LED Headlight Module2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Main Relay2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Antenna Motor2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Mirror Motor2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Seat Motor2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Window Motor - Front2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Window Motor - Rear2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Window Regulator - Front2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Power Window Regulator - Rear2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Radio/Head Unit2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Relay - Generic2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Seat Heater Element2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Side Mirror Assembly2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Speaker - Dash2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Speaker - Door2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Speedometer2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Starter3 specs
- Heat Shield BoltsIf equipped7 lb-ft10 Nm
- Starter Mounting BoltLong bolt may need extension37 lb-ft50 Nm
- Starter Solenoid NutFor B+ cable9 lb-ft12 Nm
Starter Solenoid4 specs
- Battery Cable Nut10 lb-ft14 Nm
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Starter Mounting Bolt35 lb-ft47 Nm
Subwoofer2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Sunroof Motor2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Sunroof Switch2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Tail Light Assembly3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Tail Light Bulb1 spec
- Connector Screws3 lb-ft4 Nm
Third Brake Light1 spec
- Connector Screws3 lb-ft4 Nm
Trunk/Liftgate Actuator2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Turn Signal Bulb - Front1 spec
- Connector Screws3 lb-ft4 Nm
Turn Signal Bulb - Rear1 spec
- Connector Screws3 lb-ft4 Nm
Turn Signal Switch3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Voltage Regulator2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Washer Pump2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Washer Reservoir2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Window Motor and Regulator - Front2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Window Motor and Regulator - Rear2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Wiper Linkage3 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
- Ground Strap BoltsClean contact surfaces10 lb-ft14 Nm
Wiper Motor - Front2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Wiper Motor - Rear2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Wiper Switch2 specs
- Battery Terminal Bolts5 lb-ft7 Nm
- Connector Screws3 lb-ft4 Nm
Suspension
Ball Joint - Lower8 specs
- Ball Joint Pinch BoltUse new bolt45 lb-ft61 Nm
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint Castle NutUse new cotter pin75 lb-ft102 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Ball Joint - Upper6 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Ball Joints - Upper and Lower7 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Pinch BoltNew bolt45 lb-ft61 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin64.9 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Coil Spring - Front4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Coil Spring - Rear4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Coil Springs - Front Pair4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Coil Springs - Rear Pair4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Control Arm Bushing - Front Lower5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Control Arm Bushing - Front Upper5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Control Arm Bushing - Rear5 specs
- Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Front Struts - Pair6 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Front Suspension Rebuild5 specs
- Ball Joint Pinch BoltUse new bolt if locknut style37 lb-ft50 Nm
- Lower Control Arm BoltsTorque at ride height81 lb-ft110 Nm
- Strut Top Mount Nuts18 lb-ft25 Nm
- Sway Bar End Link Nuts44 lb-ft60 Nm
- Upper Control Arm BoltsTorque at ride height66 lb-ft90 Nm
Knuckle/Spindle - Front6 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin64.9 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Knuckle/Spindle - Rear5 specs
- Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Lateral Arm4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Lower Control Arm - Front5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Lower Control Arm - Rear5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Lower Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Radius Arm4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Radius Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Rear Shocks - Pair3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Rear Suspension Service4 specs
- Lower Control Arm BoltsTorque at ride height66 lb-ft90 Nm
- Shock Lower Bolt52 lb-ft70 Nm
- Sway Bar End Link Nuts37 lb-ft50 Nm
- Trailing Arm BoltsTorque at ride height88 lb-ft120 Nm
Shock Absorber Replacement2 specs
- Lower Mount Bolt66 lb-ft90 Nm
- Upper Mount NutUse new self-locking nut41 lb-ft55 Nm
Strut Assembly - Front4 specs
- Strut Mount Center NutHold strut shaft with Allen key41 lb-ft55 Nm
- Strut to Knuckle BoltsOften TTY111 lb-ft150 Nm
- Strut Tower NutsDo not loosen center nut unless compressed37 lb-ft50 Nm
- Sway Bar End Link Nuts41 lb-ft55 Nm
Strut Assembly - Rear6 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Strut Bearing5 specs
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Strut Mount - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Strut Mount - Rear6 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Strut to Knuckle Bolts90 lb-ft122 Nm
- Strut Tower Nuts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Subframe4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Subframe Bushing4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar Bushing - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar Bushing - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar Link - Front5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar Link - Rear5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Sway Bar Links - Front Pair5 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Bracket Bolts35 lb-ft47 Nm
- Sway Bar Link45 lb-ft61 Nm
- Sway Bar Link Nuts45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Torsion Bar4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Torsion Bar Adjustment3 specs
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Trailing Arm4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Trailing Arm Bushing4 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Upper Control Arm - Front5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Upper Control Arm - Rear5 specs
- Control Arm BoltsTorque with weight on wheels95 lb-ft129 Nm
- Strut Bolts85 lb-ft115 Nm
- Sway Bar Link45 lb-ft61 Nm
- Upper Ball Joint NutUse new cotter pin65 lb-ft88 Nm
- Wheel Lug NutsTorque in star pattern89 lb-ft121 Nm
Steering
Power Steering Fluid Flush6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Power Steering Hose - High Pressure6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Power Steering Hose - Return6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Power Steering Pump8 specs
- High Pressure Hose FittingUse new O-rings18 lb-ft25 Nm
- Power Steering Pump Bolts18 lb-ft25 Nm
- Pressure Line FittingUse new O-rings22 lb-ft30 Nm
- Pulley NutHold pulley with pin spanner52 lb-ft70 Nm
- Pump Mounting Bolts18 lb-ft25 Nm
- Return Hose Clamp2 lb-ft3 Nm
- Return Line Clamp3 lb-ft4 Nm
- Serpentine Belt Tensioner41 lb-ft55 Nm
Power Steering Pump Pulley6 specs
- Coupling Bolt25 lb-ft34 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Power Steering Rack8 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Pressure Line FittingNew O-ring25 lb-ft34 Nm
- Pump Mounting Bolts20 lb-ft27 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Power Steering Reservoir5 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Rack and Pinion Boots4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Angle Sensor4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Column6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Coupler5 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Damper4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Shaft - Intermediate5 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Shaft - Upper4 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Steering Wheel6 specs
- Coupling Bolt25 lb-ft34 Nm
- Power Steering Line FittingsUse new O-rings25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Tie Rod Assembly5 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Tie Rod End - Inner6 specs
- Coupling Bolt25 lb-ft34 Nm
- Steering Rack Bolts75 lb-ft102 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Tie Rod End - Outer5 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Tie Rods - Both Sides5 specs
- Coupling Bolt25 lb-ft34 Nm
- Tie Rod End NutUse new cotter pin40 lb-ft54 Nm
- Tie Rod Lock NutAfter alignment50 lb-ft68 Nm
- Tie Rod Nut40 lb-ft54 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Drivetrain
Axle Seal - Front6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
CV Axle - Front7 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
CV Axle - Rear7 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- Ball Joint Nut75 lb-ft102 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
CV Axles - Front Pair6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Lower Ball Joint Nut75 lb-ft102 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
CV Boot - Inner5 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
CV Boot - Outer5 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Differential Cover Gasket4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Differential Fluid Change - Front4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Differential Fluid Change - Rear4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Differential Pinion Seal4 specs
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
Differential Rebuild - Front8 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Drain PlugNew washer30 lb-ft41 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Fill Plug30 lb-ft41 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Differential Rebuild - Rear8 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Drain PlugNew washer30 lb-ft41 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Fill Plug30 lb-ft41 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Driveshaft - Front3 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts (CV/U-Joint)Use new bolts if torque-to-yield55 lb-ft75 Nm
- Transfer Case Output Yoke NutIf accessible133 lb-ft180 Nm
Driveshaft - Rear3 specs
- Differential Pinion Yoke NutUse new nut, set pinion preload184 lb-ft250 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
- U-Joint Strap BoltsApply threadlocker26 lb-ft35 Nm
Driveshaft Center Support Bearing2 specs
- Center Support Bearing Bracket Bolts37 lb-ft50 Nm
- Driveshaft Flange Bolts55 lb-ft75 Nm
Front Differential6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Limited Slip Clutch Pack6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Rear Differential6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Ring and Pinion6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
U-Joint6 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Wheel Bearing - Press-In Front6 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Wheel Bearing - Press-In Rear7 specs
- ABS Sensor Bolt8 lb-ft11 Nm
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Differential Cover BoltsApply RTV sealant25 lb-ft34 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Hub Bolts75 lb-ft102 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Wheel Bearing Hub - Front4 specs
- ABS Sensor BoltDo not overtighten7 lb-ft10 Nm
- Axle NutUse new cotter pin after torque184 lb-ft250 Nm
- Caliper Bracket Bolts88 lb-ft120 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified81 lb-ft110 Nm
Wheel Bearing Hub - Rear3 specs
- Axle NutUse new cotter pin after torque148 lb-ft200 Nm
- Caliper Bracket Bolts81 lb-ft110 Nm
- Wheel Bearing Hub BoltsApply threadlocker if specified74 lb-ft100 Nm
Wheel Studs5 specs
- Axle NutUse new nut, stake after180 lb-ft244 Nm
- CV Bolts45 lb-ft61 Nm
- CV Joint Bolts45 lb-ft61 Nm
- Driveshaft Bolts55 lb-ft75 Nm
- Wheel Lug Nuts89 lb-ft121 Nm
Transmission
Clutch Hydraulic Line4 specs
- Bell Housing Bolts35 lb-ft47 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Pressure Plate BoltStar pattern20 lb-ft27 Nm
Dual Mass Flywheel2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Manual Trans Fluid Change2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Neutral Safety Switch2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Overdrive Solenoid2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Pressure Plate2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Shift Cable2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Shift Fork2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Shift Linkage2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Synchros - All2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Synchros - Single Gear2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Control Module2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Cooler Lines2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Filter2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Filter and Fluid2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Fluid Change5 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
- Transmission Drain PlugUse new crush washer if equipped22 lb-ft30 Nm
- Transmission Filter BoltsIf equipped with bolted filter6 lb-ft8 Nm
- Transmission Pan BoltsTighten in criss-cross pattern9 lb-ft12 Nm
Transmission Flush2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Input Shaft Bearing2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Oil Cooler7 specs
- Drain PetcockHand tight5 lb-ft7 Nm
- Drain PlugUse new washer25 lb-ft34 Nm
- Fan Bolts8 lb-ft11 Nm
- Fill Plug25 lb-ft34 Nm
- Hose ClampsDo not overtighten3 lb-ft4 Nm
- Pump BoltsTorque in sequence18 lb-ft24 Nm
- Thermostat Housing Bolt10 lb-ft14 Nm
Transmission Output Shaft Bearing2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Pan Gasket2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission R&R - Automatic2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission R&R - Manual2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Range Sensor2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Rebuild - Automatic2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Rebuild - Manual2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Speed Sensor - Input2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Transmission Speed Sensor - Output2 specs
- Drain PlugUse new washer25 lb-ft34 Nm
- Fill Plug25 lb-ft34 Nm
Exhaust
Air Injection Check Valve3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Catalytic Converter - Direct Fit4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Catalytic Converter - Universal4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Downpipe4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
EGR Tube3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
EGR Valve4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Exhaust Clamp3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Exhaust Gasket - Front4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Exhaust Gasket - Rear3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Exhaust Hangers3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Exhaust Manifold Studs4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Exhaust Pipe - Rear Section3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Exhaust Tip2 specs
- Hanger Bolts15 lb-ft20 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Flex Pipe4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Front Pipe4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Intermediate Pipe4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Muffler2 specs
- Hanger Bracket Bolts18 lb-ft25 Nm
- Muffler Clamps41 lb-ft55 Nm
O2 Sensor - Downstream4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
O2 Sensor - Upstream4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
O2 Sensors - All4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Resonator4 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
- O2 SensorApply anti-seize to threads35 lb-ft47 Nm
Secondary Air Injection Pump3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Tail Pipe3 specs
- Hanger Bolts15 lb-ft20 Nm
- Heat Shield Bolts10 lb-ft14 Nm
- Manifold NutsApply anti-seize25 lb-ft34 Nm
Heating and A/C
AC Accumulator5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Clutch Coil4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Compressor3 specs
- AC Compressor Bolts18 lb-ft25 Nm
- AC Line FittingsUse new O-rings, add PAG oil15 lb-ft20 Nm
- Clutch Connector Bolt6 lb-ft8 Nm
AC Compressor Clutch4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Compressor Oil Add5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Condenser2 specs
- AC Line FittingsUse new O-rings15 lb-ft20 Nm
- Condenser Mounting Bolts9 lb-ft12 Nm
AC Evaporator7 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw3 lb-ft4 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Evaporator Case Screws5 lb-ft7 Nm
- Expansion Valve FittingUse new O-rings8 lb-ft11 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Expansion Valve (TXV)5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC High Pressure Switch5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose - High Side5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose - Low Side5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Hose Assembly5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Low Pressure Switch5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Orifice Tube5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Pressure Sensor5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Receiver/Drier5 specs
- AC Line FittingsNew O-rings15 lb-ft20 Nm
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
AC Recharge4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Blend Door Actuator4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Cabin Air Filter4 specs
- Compressor Bolts25 lb-ft34 Nm
- Connector Bolts5 lb-ft7 Nm
- Filter Cover ClipsTool-free on most2 lb-ft3 Nm
- Glove Box Screws3 lb-ft4 Nm
Climate Control Module4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
HVAC Control Panel4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Mode Door Actuator4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Recirculation Door Actuator4 specs
- Blower Motor Mounting Screw5 lb-ft7 Nm
- Compressor Bolts25 lb-ft34 Nm
- Duct Clips2 lb-ft3 Nm
- Mounting Bracket Bolts18 lb-ft24 Nm
Body
Bumper Cover - Front5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Cover - Rear5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Reinforcement - Front5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Bumper Reinforcement - Rear5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Check/Stop5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Glass5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Exterior5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Handle - Interior5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Hinge5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Shell5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Skin5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Door Weatherstrip5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Fender Liner5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Grille5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Hinge5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Latch5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Release Cable5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Hood Strut5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Glass5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Quarter Panel5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Rear Window5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Rocker Panel5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Side Mirror Glass5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Hinge5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Latch5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Lid5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Trunk Strut5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Windshield Molding5 specs
- Hinge Bolts20 lb-ft27 Nm
- Latch Bolts10 lb-ft14 Nm
- Panel Bolts10 lb-ft14 Nm
- Striker Bolts25 lb-ft34 Nm
- Trim ClipsReplace if broken2 lb-ft3 Nm
Interior
Armrest1 spec
- Connector Bolts5 lb-ft7 Nm
Carpet1 spec
- Connector Bolts5 lb-ft7 Nm
Center Console1 spec
- Connector Bolts5 lb-ft7 Nm
Dash Pad1 spec
- Connector Bolts5 lb-ft7 Nm
Dashboard1 spec
- Connector Bolts5 lb-ft7 Nm
Door Panel1 spec
- Connector Bolts5 lb-ft7 Nm
Floor Mat Hooks1 spec
- Connector Bolts5 lb-ft7 Nm
Glove Box1 spec
- Connector Bolts5 lb-ft7 Nm
Glove Box Latch1 spec
- Connector Bolts5 lb-ft7 Nm
Headliner1 spec
- Connector Bolts5 lb-ft7 Nm
Pedal Pads1 spec
- Connector Bolts5 lb-ft7 Nm
Rearview Mirror1 spec
- Connector Bolts5 lb-ft7 Nm
Seat - Front1 spec
- Connector Bolts5 lb-ft7 Nm
Seat - Rear1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Belt1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Belt Buckle1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Belt Pretensioner1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Cover1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Foam1 spec
- Connector Bolts5 lb-ft7 Nm
Seat Track1 spec
- Connector Bolts5 lb-ft7 Nm
Shifter Boot1 spec
- Connector Bolts5 lb-ft7 Nm
Shifter Knob1 spec
- Connector Bolts5 lb-ft7 Nm
Steering Wheel Cover1 spec
- Connector Bolts5 lb-ft7 Nm
Sun Visor1 spec
- Connector Bolts5 lb-ft7 Nm
Torque is shown in lb-ft with Nm below it. Where a step says to turn, tighten the listed angle after the torque step before it. Use new bolts where the note says so.
Need labor times, fluids or repair steps for this car? See it on the Open Labor Project